Table of Contents
The 4th generation Ford Mondeo was produced in 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014 with both gasoline and diesel engines. During this time, the car went through one restyling. In our publication you can find a description of the Ford Mondeo 4 fuse blocks and relays, their locations, diagrams and photos - examples of execution. Note the fuse responsible for the cigarette lighter.
This model has 3 main blocks with fuses and relays: under the hood, in the passenger compartment and in the luggage compartment.
In the passenger compartment
It is located under the glove compartment. To access, you just need to turn the fastening screw and the unit will drop down.
Type 1
Diagram.
| № | Description |
| F1 | 5A Rain sensor |
| F2 | 10A SRS (airbag) power supply |
| F3 | 5A Course deviation sensor (ESP), electric parking brake |
| F4 | 7.5A Power supply, accelerator pedal, electronic fuse |
| F5 | 15A Rear wiper |
| F6 | 15A Audio system (including voice control) |
| F7 | 7.5A Steering wheel module |
| F8 | 5A Dashboard |
| F9 | 15A High beam headlights |
| F10 | 20A Electric ventilation hatch |
| F11 | 7,5А Reversing lights |
| F12 | Reserve |
| F13 | 15A Front fog lamp bulb |
| F14 | 15A Windshield washer |
| F15 | 10A Adaptive cruise control system (ACC) |
| F16 | Reserve |
| F17 | 10A Interior lampshades |
| F18 | 5A Engine Immobilizer |
| F19 | 15A Cigarette lighter |
| F20 | Reserve |
| F21 | 5A Radio signal receiver, rain sensor |
| F22 | 20A Fuel pump |
| F23 | Reserve |
| F24 | 5A Ignition switch (starter and instruments) |
| F25 | 10A Fuel filler flap |
| F26 | 5A Autonomous sound system (alarm system), OBD II (on-board computer diagnostics) |
| F27 | 5A Steering column assembly, climate control unit |
| F28 | 5A Brake light switch |
Type 2
General view.
| Diagram | |
|---|---|
|
|
| № | Designation |
| F1 | 7.5A Steering wheel module |
| F2 | 5A Dashboard |
| F3 | 10A Interior lampshades |
| F4 | 5A Engine Immobilizer |
| F5 | 7.5A Adaptive Cruise Control (ACC) |
| F6 | 5A Rain sensor |
| F7 | 20A Cigarette lighter |
| F8 | 10A Power supply of the chain for unlocking the fuel filler flap |
| F9 | 15A Windshield washers - rear |
| F10 | 15A Windshield washers - front |
| F11 | 10A Power supply for the tailgate unlock circuit |
| F12 | 10A Power supply of the chain for locking the fuel filler flap |
| F13 | 7,5 / 20A Fuel pump |
| F14 | 5A Remote frequency receiving, interior motion sensor |
| F15 | 5A Ignition switch (starter and instruments) |
| F16 | 5A Autonomous sound system (burglar alarm system), OBDII (on-board computer diagnostics) |
| F17 | 5A Steering wheel vibration sensor |
| F18 | 10A SRS (airbag) power supply |
| F19 | 7.5A ABS, Yaw Rate Sensor (ESP), Electric Parking Brake (EPB), Accelerator Pedal Power |
| F20 | 7.5A Electronic power supply, electronic fuse, self-dimming mirror, lane departure warning system |
| F21 | 15A Power supply for radio |
| F22 | 5A Brake light switch |
| F23 | 20A Roof hatch |
| F24 | 5A Power supply to the climate control module and the steering column control module |
| The fuse number 20 at 7A is responsible for the Ford Mondeo 4 cigarette lighter. | |
In the engine compartment
It is located on the left side next to the headlight, under the protective cover. Consists of 2 parts: fuse section and high power fuse section.
| Photo - diagram | |
|---|---|
|
|
|
|
| № | Description |
| F1 | 10 / 15A Transmission control module |
| F2 | Diesel Engines: Glow Plug Control, Evaporator Glow Plug Monitoring (Restyled: 2.0L Duratorq-TDCi Stage V and 2.2L Duratorq-TDCi Stage V) |
| F3 | 70A 2.3L Duratec-HE and 2.2L Duratorq-TDCi with automatic transmission: Engine cooling fan - dual fan 80A Electro-hydraulic power steering (EHPAS) (1.6L Duratec-16V Ti-VCT Stage V, 1.6L EcoBoost SCTi, 2.0L EcoBoost SCTi , 1.6L Duratorq-TDCi Stage V and 2.0L Duratorq-TDCi Stage V, 2.0L Duratorq-TDCi) |
| F4 | 60A Glow plugs |
| F5 | 60 / 70A Engine cooling fan (twin fan) |
| F6 | 7.5 / 10A HEGO 1 sensors (engine management), variable valve timing (engine management), CMS sensor, oxygen sensor 20A Evaporator glow plug |
| F7 | 5A Solenoids Relay |
| F8 | 10/15 / 20A Powertrain control module, fuel meter, MAF sensor, fuel manifold pressure control valve (engine management system) |
| F9 | 10A MAF sensor, fuel injectors, variable inlet valve, variable outlet valve, ignition coils (engine management system) 5A Fuel pump evaporator 7.5A Mass air flow sensor, EGR bypass valve, fuel pump evaporator engine management) or for 1.6L Valve cooling system air removal, TMAF sensor, active radiator shutters, bypass valve, relay coil, auxiliary water pump |
| F10 | 10A Engine control unit 7.5A Auxiliary water pump |
| F11 | 5 / 7.5 / 10A PCV valve, VCV valve, water in fuel sensor, purge valve, swirl valve, variable inlet valve, EGR valve, IVVT oil control valve (engine management system) T.MAF sensor, variable hold valve exhaust time, active radiator shutters, canister purge valve, turbocharger control valve, boost pressure regulator (engine management system) 1.6L EcoBoost SCTi: Turbocharger pressure control valve, variable intake valve, variable exhaust valve, charcoal purge valve fuel vapor control filter, electric bypass valve |
| F12 | 10 / 15A Coil complete with spark plug; canister purge valve, power steering pressure sensor (engine management system) 5A Relay coil |
| F13 | 15A Air conditioning |
| F14 | 10 / 15A 2.0L Diesel filter heater, HEGO sensor |
| F15 | 40A Starter relay |
| F16 | 80A Auxiliary Diesel Heater (PTC) |
| F17 | 60A Power supply A of the central fuse box |
| F18 | 60A Power supply B of the central fuse box |
| F19 | 60A Power supply From the central fuse box |
| F20 | 60A Power supply D of the central fuse box |
| F21 | 30A VQM / without VQM: instrument cluster / audio unit / AC / FLR |
| F22 | 30A Wiper blade module |
| F23 | 25 / 30A Heated rear window |
| F24 | 30A Headlight washers |
| F25 | 30A ABS valves |
| F26 | 40A ABS pump |
| F27 | 25A Auxiliary fuel heater |
| F28 | 40A Heater fan |
| F29 | Reserve |
| F30 | 5A Power supply ABS 30 |
| F31 | 15A Sound signal |
| F32 | 5A Fuel fired heater - remote control |
| F33 | 5A Lighting control unit, engine compartment fuse block solenoids |
| F34 | 40A Heated windshield, left side |
| F35 | 40A Heated windshield, right side |
| F36 | 15A Power supply for rear wiper 15 5A ABS |
| F37 | 7,5 / 10А Heated front washer nozzles / FLR + FSM KL15 |
| F38 | 10A Power supply PCM / TCM / EHPAS 15 5A Adaptive cruise control (ACC) |
| F39 | 15A Adaptive Lighting System (AFS) |
| F40 | 5A Headlight range control / AFS module |
| F41 | 20A Instrument panel |
| F42 | 5A Shield IP 10A Engine control module, transmission control module, electro-hydraulic power steering (EHPAS), 15, power supply |
| F43 | 15A Audio unit / brake valve closing module (BVC) / digital audio broadcasting module (DAB) 5A Headlight position, adaptive headlight system (AFS) |
| F44 | 5A Automatic AC system / Manual AC system |
| F45 | 5A FLR (start / stop) 15A Rear window wiper |
In the luggage compartment
It is located on the left behind the side trim. Various designs are possible depending on the vehicle body and its equipment.
| Diagrams | |
|---|---|
| Sedans | |
|
|
| Station wagons | |
|
|
| № | General decoding of elements |
| FA1 | Left front door control unit (power windows, central locking, folding mirrors, heated mirrors) |
| FA2 | Front right door control unit (power windows, central locking, folding mirrors, heated mirrors) |
| FA3 | Rear left door control unit (power windows) |
| FA4 | Rear right door control unit (power windows) |
| FA5 | Rear door locking without door control units |
| FA6 | Power sockets for connecting additional equipment |
| FA7 | Relay solenoids |
| FA8 |
|
| FA9 | VQM relay coils (start / stop) |
| FA10 | Electric driver's seat adjustment |
| FA11 | Accessories, trailer module |
| FA12 | Electric driver's seat adjustment |
| FB1 | Parking aid module |
| FB2 | Suspension control unit |
| FB3 | Heated driver's seat |
| FB4 | Heated front passenger seat |
| FB5 | Heated rear left seat |
| FB6 | Reserve |
| FB7 | Heated rear right seat |
| FB8 | Parking aid, BLIS |
| FB9 | Front passenger seat electrically adjustable |
| FB10 | Anti-theft alarm |
| FB11 | Reserve |
| FB12 | Reserve |
| FC1 | Reserve |
| FC2 | Reserve |
| FC3 | Reserve |
| FC4 | Reserve |
| FC5 |
|
| FC6 | Reserve |
| FC7 | 5A Seat memory function module |
| FC8 |
|
| FC9 | 20A Audio amplifier |
| FC10 | 10A Sony audio system |
| FC11 | Reserve |
| FC12 | Reserve |
Having a problem with full beam. The f9 fuse is not blown the bulbs are not blowing the wires are all connected and not loose. This has stumped me