Fuses and relays Mazda 5 (CR), 2004 - 2010

The Mazda 5 minivan has been produced in two generations since 1994. We will show the location of all Mazda 5 electronic control units for cars 2004, 2005, 2006, 2007, 2008, 2009, 2010 model years. Consider in detail the diagrams of the fuse blocks and the Mazda 5 relay with a description of the purpose of their elements. Note the cigarette lighter fuse.


 

General layout of electrical control units
Description
1 Air conditioning control unit (in the heater control panel)
2 Little light sensors (air conditioning)
3 Heater / A / C Blower Motor Resistor (Automatic Temperature Control) - Passenger Footwell
4 Heater / A / C blower motor resistor (manual temperature control) - driver's footwell
5 Antenna unit, in front, (keyless entry system)
6 Antenna unit, in salon (keyless entry system)
7 Antenna unit, rear (keyless entry system)
8 Antenna unit, rear door (keyless entry system)
9 Shock sensor (SRS), front
10 Volume change sensor (anti-theft system), front - with sunroof
11 Volume change sensor (anti-theft system), front - without sunroof
12 Volume change sensor (anti-theft system), rear
13 Anti-theft alarm sound - left side of luggage compartment
14 Interference Suppressor (Audio) - Luggage Compartment Left Side
15 Accumulator battery
16 Central locking signal control unit
17 Diagnostic connector (DLC)
18 Rear left door electrical control unit - left side of luggage compartment
19 Right rear door electronics control unit - right side of luggage compartment
20 Power control unit glass lifter (in the switch on the driver's door)
21 Cooling fan electric motor control unit
22 Fuse / relay box, engine compartment
23 Fuse / relay box dashboard
24 Xenon headlamp control unit, left
25 Xenon headlamp control unit, right
26 Headlight washer pump
27 Beep (top)
28 Beep (bottom)
29 Immobilizer Control Unit - In Instrument Cluster
30 Immobilizer ring antenna - near the ignition switch
31 Interior temperature sensor
32 Direction indicator relay - in the multifunction control unit
33 Instrument cluster control unit (in the dashboard)
34 Keyless entry system control unit
35 light sensor
36 Multifunctional control unit - functions: Anti-theft system, central locking, outside lamps, turn signals / hazard warning lights, fog lamps, rear window wiper / washer, windshield wiper / washer
37 Navigation antenna - behind the dash
38 Navigation control unit
39 Ambient temperature sensor
40 Power steering control unit - in the power steering pump
41 Rear window washer pump motor
42 Additional fuse (petrol - 250A / Diesel - 450A) - power distribution (charging and starting systems)
43 Side impact sensor, front left - B-pillar lower
44 Side airbag sensor, rear left
45 Side impact sensor, front right - B-pillar lower
46 Side airbag sensor, rear right
47 Steering wheel position sensor (power steering system) - under the steering wheel
48 Sunroof electric control unit
49 SRS electronic control unit
50 Body height sensor (rear) - on the suspension
51 Electronic gearbox control unit (automatic transmission) - in the electronic engine control unit (diesel)
52 Electronic gearbox control unit (automatic transmission) - in the electronic engine control unit (petrol)
53 Vehicle speed sensor - ABS electronic control unit
54 Voice synthesizer (navigation system)
55 Buzzer ("keyless entry" system) - behind the front left wheel arch trim
56 Windshield washer fluid low level sensor
57 Windshield washer pump motor
58 Rain sensor (windshield wiper)

Passenger compartment fuse box



It is located at the right end of the dashboard behind the protective cover.

Diagram
Description
1 7.5A M.DEF - Heated mirrors (some models)
2 10A STARTER - Starter
3 20А ENG3 - Engine control unit
4 15А P.OUTLET - Connector for accessories
5 5A SHIFT / L - Transmission switch
6 15А CIGAR - Cigarette lighter
7 7.5А MIRROR - Mirror, power adjustment, audio system (some models)
8 10A A / C - Air Conditioning
9 25А F.WIP - Wipers and windshield washer
10 15А R.WIP - Rear window wiper and washer
11 5A Main relay (some models), PCM (some models)
12 10A METER - Instrument panel. Automatic headlight range control (some models)
13 10A SAS - Additional restraint systems, SRS
14 Seat heating (some models)
15 5F ABS, DSC - ABS
16 5A EHPAS - Electro-hydraulic power steering
17 15А ENG2 - Engine management
18 P / W - Electric windows
19 P / W - Electric windows
The fuses 4 and 6 at 15A are responsible for the operation of the cigarette lighter.

Under the hood


Fuse box Installed on the left side of the engine compartment next to the battery.


Photo - an example of execution.

Diagram
Purpose of fuses
1 30A FAN - Cooling fan
2 30A FAN - Cooling fan
3 40A P.WIND - Electric windows
3 30A R. BLOWER - Rear fan motor
4 30A IG KEY1 INJ - To protect various circuits
4 20A IG KEY2 - To protect various circuits
5 20A ABS-V ABS
6 30A ABS-R - ABS
7 20A IG KEY2 - To protect various circuits
7 40A IG KEY1 - To protect various circuits
8 20А HEATER DEICER TCM - Heater (defroster)
9 40A BLOWER - Fan motor
20A F.BLOWER - Front fan motor
10 40A GLOW IG KEYl - For protection of various circuits
20A F.BLOWER - Front fan motor
11 60A BTN - For protection of various circuits
12 40A IG KEY2 - To protect various circuits
13 20А CLOSER P.SLIDE LH - Left door closer
14 20А CLOSER P.SLIDE RH - Right door closer
15 80A EHPAS - Electro-hydraulic power steering
16 15А FOG - Fog lights
17 20А D.LOCK - Electric door lock
18 20А P.WIND H / CLEAN - Electric windows
19 10A ETC - Accelerator Position Sensor
20 25А DEFOG - Heated rear window
21 10А ENG + B - PCM unit
22 10A STOP - Brake lights
23 20А FUEL Pump - Fuel pump
24 10А HAZARD - Direction indicators, hazard warning lights
25 15A ROOM - Interior lighting, Luggage compartment lighting
26 Reserve
27 10A MAG - Magnetic clutch
28 7,5А GLOW SIC - Candles
29 10A HEAD HR - High beam headlights (right)
30 10A HEAD HL - High beam headlights (left)
31 15А HORN - Signal
32 20А SUN ROOF - Luke
33 7,5А MIRROR BURGLAR - Anti-theft system (some models)
33 Reserve
34 15A HEAD LR - Dipped headlights (right), manual headlight range control
35 15A HEAD LL - Low beam headlights (left)
36 15А ENG BAR2 - O2 heater
37 15А ENG BAR2 - Air flow sensor, Engine management system
38 20А INJ ENG BA - Injector
39 10А ILLUMI - Lighting
40 10A TAIL - Rear lights, Parking lights, License plate light
Relay decoding
  DEFOG - Heated rear window relay
  TNS - Relay for outdoor lighting (dimensions)
  AT PUMP - Transmission relay
  HEAD LO - Low beam relay
  HEAD HI - High beam relay
  F / WARMER - Fuel heating relay
  FANS - Fan relays
  A / C - Air conditioner relay
  HORN - Signal relay


There is a high power main fuse on the positive terminal of the battery.

Related materials
Add new comment