Fuses and relays Renault Magnum 4, 2005 - 2013

Renault Magnum is a long-haul truck tractor produced in four generations from 1990 to 2014 with different engine sizes. The most popular are the Renault Magnum dxi engines with a capacity of 440, 460 and 480 hp. from. In this publication, we show a description of Renault Magnum fuses and relays with block diagrams and their locations. Note the fuse responsible for the cigarette lighter.


The design of the blocks and the purpose of the elements in them depends on the year of manufacture, generation and engine. Check the purpose with your description on the back of the protective cover or other technical documentation.

Fuse and relay box

Type 1

Photo - example.

Diagram
Description
Trailer socket 7-pin "ABS / EBS" F1
Power supply of pilot lamps "SERVICE" and "DANGEROUS" F1
control unit "ABS / ASR" F1
fuse for the "ABS / ASR" solenoid valves (Front right / Rear left) F1
fuse for the "ABS / ASR" solenoid valves (Front left / Rear right) F1
ABS emergency protection fuse F1
fuse for electric retarder disconnecting unit F1
Parking lights, right F2
Side lights, right F2
Parking lights left F3
Left side lights F3
Power supply for trailer parking lights F4
Reserve +24 volts (for lighting) F5
Reserve +24 volts (for lighting) F6
Instrument panel illumination F6
Illumination of switches F6
Fog lamp (or lanterns) F8
Fog lights F9
Low beam headlamp, right F10
Low beam headlamp, left F11
High beam headlamp, left F12
High beam headlamp, right F13
Long range floodlights F14
Stroke drive for wipers F15
Anti-theft device F16
Brake light switch under the brake pedal F16
Reversing lights F16
Emergency switch "TBV" (RTMDR modification) F16
Instrument panel warning lamps supply circuit F16
heated door mirrors F16
Air conditioner circuit F18
Roof hatch motor F20
Backup power supply (after the general switch) F21
Autonomous heater "D1LCC" F22
Autonomous heater "D3LCC" (hairdryer) F22
Autonomous heater "Thermo 90" (wet) F22
Air conditioner circuit F22
Ventilation control device F22
footrest backlight fuse F23
Driver's light F23
Sleeper ceiling F23
Lower couch ceiling F23
Upper couch ceiling F23
Portable card reading lamp F23
Passenger power window motor F24
Control tachograph clock F25
Buzzer F26
Stop signal F27
control unit "ABS / ASR" F28
Defrosting Swivel Mirror, Left F29
Swivel mirror with defrosting, right F29
Outside mirror (s) orientation control F29
Power supply of additional elements of the control tachograph F30
Spotlight adjustment drives F30
cigarette lighter fuse F30
12 volt converter (telecommunication circuit) walkie talkie F30
radio fuse F30
Wiper drive motor F32
washer motor F32
headlight washer motor F32
fuse socket for diagnostics F33
suspension control unit (6 × 2/6 × 4) F33
Interrupter, direction indicator F34
Power supply of memory of an auto radio receiver F34
Programmable switch (remote control) of the auxiliary heater F34
Backup power (after contact of the starter lock F35
EBS control unit F37
Motor glass lifter driver F38
Backup power supply (after the general switch) F40
Dot matrix display F42
control unit "TBV" F42
Working spotlight (tractor) F43
Valve illumination F43
Central locking control unit F45
Electric latch left F45
Electric latch right F45
Engine heater switch F46
Time relay for centralized lubrication system F46
Dot matrix display F46
suspension computer (4 × 2) F47
suspension computer (6 × 2/6 × 4) F47
Suspension remote control unit F47
Rear axle cushion pressure sensor (6 × 2) F47
Self-aligning axis timing relay F47
computer "VMAC" F48
Exhaust brake solenoid valves "J" F49
Refrigerator F50
Heated driver's seat F51
Heated passenger seat F51
Step-down transformer (for 12 volt socket) F51
Socket for "SAE" F51
Backup power for video F53
Electric front sunblind F54
Electric side sun blinds F54
Backup power (after starter lock contact) F55
Emergency switch "TBV" (RTMDR version F56
control unit "TBV" F56
EBS control unit F60

The fuse F30 is responsible for the cigarette lighter.

Separately, outside the unit, fuses can be installed:

  • Cab tipping pump - F84 40 A10
  • Trailer socket 7-pin "ABS / EBS" - F85 20 A3

Relay decoding

Power relay after contact RP1
Power relay after contact RP2
Oil pressure switch R4
Parking light relay R5
Relay for additional comfort elements R6
Lighting relay R8
Fog lamp relay R9
Fog lamp relay R10
Headlamp low beam relay R11
Headlamp high beam relay R12
Long Range Spotlight Relay R13
Brake light relay R14
Back-up relay R17
Electric retarder shutdown relay R18
Relay for defrosting mirrors R20
Brake pad relay R26
Exhaust brake relay "J" R30
Backup relay (for future connections) R40
Backup relay (for future connections) R43
Power relay of the control unit "VMAC" R44
A / C compressor relay R46
Back-up relay R47
Back-up relay R48
Air conditioning relay R49
Headlight washer timing relay RT53
Relay starting CE112
Engine heater relay CE20
Relay for electro valves "ABS / ASR" (Front. Left. / Rear. Right.) R15
Relay for electro valves "ABS / ASR" (Front right / Rear left) R16
ABS emergency protection relay R19
Self-aligning axis emergency shutdown relay R21
Engine stop relay (cab rollover) R23
Cab tilt relay RP45

Type 2

Photo - example.

Diagram
Description № - Amps
Main information display F03 7.5A
Safety relay and cab tilt enable
Cab tilt motor power relay
Main information display F04 5A
Pump motor washer headlights F05 30A
Main information display F06 5A
Tachograph
Vehicle control ECU F07 5A
Main information display F08 5A
Engine immobilizer ECU
Alarm ECU
ECU central locking doors
Air production control ECU
Bodybuilder by prior arrangement ECU control F09 5A
Air conditioner ECU F10 30A
Hydraulic retarder ECU F11 10A
ECU for electric retarder
Gear selector ECU F12 15A
ECU automatic transmission
Lighting control and ECU alarms F13 20A
Wiper Motor Delay Time Relay
Washer pump motor
Drive motor wipers
Cigarette lighter F14 15A
Car diagnostics socket F15 5A
Vehicle data extraction connector
Selection control F16 10A
Cross-axle differential lock warning lamp
Rear wheel lock solenoid valve
Power take-off solenoid valve No. 1
PTO engagement solenoid valve No. 2
PTO engagement solenoid valve No. 3
Center differential solenoid valve blocking
High beam headlamp F17 10A
Electric horn F18 10A
Air horn
Air conditioner ECU F19 5A
Radio F20 10A
Alarm ECU
ECU central locking doors
End connector ABS / EBS F21 20A
One overhead light on the driver's side F22 10A
Single overhead light, front passenger side
Right top lighting (door)
Driver Reading Spotlight
Front passenger reading headlight
Overhead lighting of the lower bunk
Top left lighting (door)
Top left lighting (atmosphere)
Top right lighting (atmosphere)
Upper bunk overhead lighting
Driver side lighting
Front passenger stage lighting
Steering axle locking angle sensor F23 5A
Steering axle locking angle sensor
Air suspension ECU
Steering axle ECU
Fuel heater resistor No. 2 F24 20A
Available power source (equipment in roadside warning icon) F25 10A
Available power source (lighting)
Equipment in unlocked position warning light
Light information signal light equipment
15 pin trailer connector
Available power source (after ignition) F26 15A
Driver's door lifter glass motor F27 20A
Front passenger door lift glass motor
EBS braking control system F28 20A
Automatic transmission selector F29 10A
On-board ECU control interface
Lighting control and ECU alarms F30 30A
Cab temperature control ECU F31 20A
Alarm ECU
Air / water auxiliary heater
Air / air auxiliary heater
Air conditioner ECU
Available power supply (after main switch) F32 10A
Cab tilt motor F33 30A
On-board ECU control interface F34 3A
Lighting control and ECU alarms F36 10A
Voltage converter (24V / 12V - 15A) for audio communication system F37 10A
Radio
Additional warning lights warning light F38 10A
Working spotlight
Vehicle control ECU F39 15A
Left defrost resistor for rearview mirror
Rearview mirror defrost resistor, right
Heated and Swing Mirror Power Relay
Windscreen defrost control relay
Engine control ECU F40 30A
Starter
Start relay
Air heater relay
Engine brake No. 1 solenoid valve
Exhaust brake solenoid valve
Changing the range of the electro valve
Electro valve for splitter control
Engine cooling fan speed control solenoid valve
Starter F41 15A
Start relay
Engine brake No. 1 solenoid valve
Engine brake No. 2 solenoid valve
Exhaust brake solenoid valve
Changing the range of the electro valve
Electro valve for splitter control
Air heater relay F42 10A
Engine cooling fan speed control solenoid valve
24 V socket F43 15A
Diagnostic socket of automatic transmission
Rotating lighthouse number 1 F46 15A
Rotating beacon number 2
Beacon power relay
Air production control ECU F47 7.5A
Brake holding control F48 3A
EBS braking control system
Air suspension ECU F49 5A
Vehicle power control ECU (ADR)
Steering axle ECU F51 5A
Automatic transmission selector F52 10A
Engine immobilizer ECU
Emergency stop control
Vehicle control ECU
After turning on the ignition, the power relay No. 1
After turning on the ignition, the power relay No. 2
After turning on the ignition, the power relay No. 3
Accessory Power Relay No. 1
Accessory Power Relay No. 2
Alternator Ground Relay (ADR)
Alternator chain tension resistance
Car diagnostics socket
On-board control ECU F54 10A
Hydraulic retarder ECU F57 10A
Emergency stop control F58 3A
Alternator Ground Relay (ADR)
Preliminary preparation for on-board control (ECU) F59 10A
Brake holding control
Reversing light relay
Voltage converter (24 V / 12 V) for information technology package F61 15A
24 V socket F63 15A
15 pin trailer connector F64 10A
Illumination for instruments F66 10A
Front lighting grille
Roof ventilation motor
Gear selector ECU F67 10A
ECU automatic transmission
Voltage converter (24V / 12V - 10A) for audio communication system F68 20A
Voltage converter (24V / 12V - 15A) for audio communication system
Voltage converter (24V / 12V) -12 and 24 Volt built-in sockets
Refrigeration compartment
Refrigerator
Additional 24 V socket
End connector ABS / EBS F70 10A
Available power source (after ignition) F71 15A
High beam headlights high beam F72 10A
Low beam headlamp
Available power source (generator information, engine running) F75 15A
Heated seat, right
Left Heated Seat
Car service F76 10A
Air / air auxiliary heater
Alternator Ground Relay (ADR)
Additional air / water heater solenoid valve
Available power supply (after main switch) F77 15A
Lighting and alarm control F90 3A
Rear fog lamp power relay
Headlamp high beam relay
Fog lamp power relay
Night light relay switches
Fog lamp cut-off relay if high beam headlamps are on
Skylight lantern No. 1 F91 10A
Lantern ground clearance number 2
Left front side / side lights
Right side light No. 3
Side lights, right No. 4
Right rear side / side lights
Port roof / side lights
Anti-glare overhead left side marker lights
Vehicle power control ECU (ADR)
Right front side / side lights F92 10A
Left side lights No. 1
Side lights LG No. 2
Parking lights LG No. 3
Side lights LG No. 4
Left rear side / side lights
Port roof / side lights
Glossy side lights, right, with anti-glare coating
Available Power Source (Right Tail Lamp (s)) F93 10A
15 pin trailer connector
Available power source (left tail lamp (s)) F94 10A
15 pin trailer connector
Devices and controls for night lighting F96 3A
Available power source (night lighting) F97 5A
High beam headlights high beam F100 15A
Fog lights
High beam headlamp
Low beam headlamp
Left fog lamp
Right fog lights
Fog lights F101 10A
Rear fog lamp
Rear fog lamp
15 pin trailer connector
Main information display F102 10A
Right high beam high beam
Left high beam high beam
Available power supply (reverse information) F103 10A
Reverse brake control
Reversing lights
Reversing lights
Outer horn
15 pin trailer connector
Left brake lights F104 10A
Right brake lights
15 pin trailer connector
Nitrogen oxide gas concentration sensor F107 10A
AdBlue feed pump module
Engine Water Bypass Solenoid Valve
Air / additional heater F108 20A

The fuse number 14, 15A, is responsible for the cigarette lighter.

Relay designation

After turning on the ignition, the power relay No. 1 R01
After turning on the ignition, the power relay No. 2 R02
After turning on the ignition, the power relay No. 3 R03
Heated and Swing Mirror Power Relay R04
Generator controlled power relay (engine running) R05
Left and right side relay / side and side light power relay R06
Night light relay switches R07
Headlamp high beam relay R08
Alternator Ground Relay (ADR) R09
Auxiliary heater power relay R10
Safety relay and cab tilt enable R11
Right and left side relay / side light and side light power relay (trailer and bodywork) R12
Brake light supply relay R13
High beam relay R14
Wiper Motor Delay Time Relay R15
Power supply relay for automatic transmission ECU R16
Start relay R17
Rear fog lamp power relay R18
Air Suspension Power Relay R19
Power relay for vehicle ECU and engine R20
Accessory Power Relay No. 1 R21
Accessory Power Relay No. 2 R22
Fog lamp power relay R23

Some models have additional high power fuses on the battery cover.

Related materials
Add new comment