Fuses and relays Renault Premium, 2006 - 2013

Renault Premium is a semitrailer main tractor that was produced in several generations from 1996 to 2013 in various modifications. The most popular were models with 380 hp dxi engines from and at 420 dci.  In this publication, we will show a description of Renault Premium fuses and relays with block diagrams and their locations. Note the cigarette lighter fuse.


The design of the blocks and the purpose of the elements in them may differ from the one presented and depends on the year of manufacture and equipment of your Renault premium. Check the description with your technical documentation or the diagram on the back of the protective cover.

Fuse and relay box

The main box is located in the passenger compartment, in the instrument panel on the passenger side, behind the cover.

Type 1


Example of the block cover


General view.

Diagram
Description № - Amps
Main information display F03 7.5A
Safety relay and cab tilt enable
Cab tilt motor power relay
Main information display F04 5A
Pump motor washer headlights F05 30A
Main information display F06 5A
Tachograph
Vehicle control ECU F07 5A
Main information display F08 5A
Engine immobilizer ECU
Alarm ECU
ECU central locking doors
Air production control ECU
Bodybuilder by prior arrangement ECU control F09 5A
Air conditioner ECU F10 30A
Hydraulic retarder ECU F11 10A
ECU for electric retarder
Gear selector ECU F12 15A
ECU automatic transmission
Lighting control and ECU alarms F13 20A
Wiper Motor Delay Time Relay
Washer pump motor
Drive motor wipers
Cigarette lighter F14 15A
Car diagnostics socket F15 5A
Vehicle data extraction connector
Selection control F16 10A
Cross-axle differential lock warning lamp
Rear wheel lock solenoid valve
Power take-off solenoid valve No. 1
PTO engagement solenoid valve No. 2
PTO engagement solenoid valve No. 3
Center differential solenoid valve blocking
High beam headlamp F17 10A
Electric horn F18 10A
Air horn
Air conditioner ECU F19 5A
Radio F20 10A
Alarm ECU
ECU central locking doors
End connector ABS / EBS F21 20A
One overhead light on the driver's side F22 10A
Single overhead light, front passenger side
Right top lighting (door)
Driver Reading Spotlight
Front passenger reading headlight
Overhead lighting of the lower bunk
Top left lighting (door)
Top left lighting (atmosphere)
Top right lighting (atmosphere)
Upper bunk overhead lighting
Driver side lighting
Front passenger stage lighting
Steering axle locking angle sensor F23 5A
Steering axle locking angle sensor
Air suspension ECU
Steering axle ECU
Fuel heater resistor No. 2 F24 20A
Available power source (equipment in roadside warning icon) F25 10A
Available power source (lighting)
Equipment in unlocked position warning light
Light information signal light equipment
15 pin trailer connector
Available power source (after ignition) F26 15A
Driver's door lifter glass motor F27 20A
Front passenger door lift glass motor
EBS braking control system F28 20A
Automatic transmission selector F29 10A
On-board ECU control interface
Lighting control and ECU alarms F30 30A
Cab temperature control ECU F31 20A
Alarm ECU
Air / water auxiliary heater
Air / air auxiliary heater
Air conditioner ECU
Available power supply (after main switch) F32 10A
Cab tilt motor F33 30A
On-board ECU control interface F34 3A
Lighting control and ECU alarms F36 10A
Voltage converter (24V / 12V - 15A) for audio communication system F37 10A
Radio
Additional warning lights warning light F38 10A
Working spotlight
Vehicle control ECU F39 15A
Left defrost resistor for rearview mirror
Rearview mirror defrost resistor, right
Heated and Swing Mirror Power Relay
Windscreen defrost control relay
Engine control ECU F40 30A
Starter
Start relay
Air heater relay
Engine brake No. 1 solenoid valve
Exhaust brake solenoid valve
Changing the range of the electro valve
Electro valve for splitter control
Engine cooling fan speed control solenoid valve
Starter F41 15A
Start relay
Engine brake No. 1 solenoid valve
Engine brake No. 2 solenoid valve
Exhaust brake solenoid valve
Changing the range of the electro valve
Electro valve for splitter control
Air heater relay F42 10A
Engine cooling fan speed control solenoid valve
24V power outlet F43 15A
Diagnostic socket of automatic transmission
Rotating lighthouse number 1 F46 15A
Rotating beacon number 2
Beacon power relay
Air production control ECU F47 7.5A
Brake holding control F48 3A
EBS braking control system
Air suspension ECU F49 5A
Vehicle power control ECU (ADR)
Steering axle ECU F51 5A
Automatic transmission selector F52 10A
Engine immobilizer ECU
Emergency stop control
Vehicle control ECU
After turning on the ignition, the power relay No. 1
After turning on the ignition, the power relay No. 2
After turning on the ignition, the power relay No. 3
Accessory Power Relay No. 1
Accessory Power Relay No. 2
Alternator Ground Relay (ADR)
Alternator chain tension resistance
Car diagnostics socket
On-board control ECU F54 10A
Hydraulic retarder ECU F57 10A
Emergency stop control F58 3A
Alternator Ground Relay (ADR)
Preliminary preparation for on-board control (ECU) F59 10A
Brake holding control
Reversing light relay
Voltage converter (24 V / 12 V) for information technology package F61 15A
24 V socket F63 15A
15 pin trailer connector F64 10A
Illumination for instruments F66 10A
Front lighting grille
Roof ventilation motor
Gear selector ECU F67 10A
ECU automatic transmission
Voltage converter (24V / 12V - 10A) for audio communication system F68 20A
Voltage converter (24V / 12V - 15A) for audio communication system
Voltage converter (24V / 12V) -12 and 24 Volt built-in sockets
Refrigeration compartment
Refrigerator
Additional 24 V socket
End connector ABS / EBS F70 10A
Available power source (after ignition) F71 15A
High beam headlights high beam F72 10A
Low beam headlamp
Available power source (generator information, engine running) F75 15A
Heated seat, right
Left Heated Seat
Car service F76 10A
Air / air auxiliary heater
Alternator Ground Relay (ADR)
Additional air / water heater solenoid valve
Available power supply (after main switch) F77 15A
Lighting and alarm control F90 3A
Rear fog lamp power relay
Headlamp high beam relay
Fog lamp power relay
Night light relay switches
Fog lamp cut-off relay if high beam headlamps are on
Skylight lantern No. 1 F91 10A
Lantern ground clearance number 2
Left front side / side lights
Right side light No. 3
Side lights, right No. 4
Right rear side / side lights
Port roof / side lights
Anti-glare overhead left side marker lights
Vehicle power control ECU (ADR)
Right front side / side lights F92 10A
Left side lights No. 1
Side lights LG No. 2
Parking lights LG No. 3
Side lights LG No. 4
Left rear side / side lights
Port roof / side lights
Glossy side lights, right, with anti-glare coating
Available Power Source (Right Tail Lamp (s)) F93 10A
15 pin trailer connector
Available power source (left tail lamp (s)) F94 10A
15 pin trailer connector
Devices and controls for night lighting F96 3A
Available power source (night lighting) F97 5A
High beam headlights high beam F100 15A
Fog lights
High beam headlamp
Low beam headlamp
Left fog lamp
Right fog lights
Fog lights F101 10A
Rear fog lamp
Rear fog lamp
15 pin trailer connector
Main information display F102 10A
Right high beam high beam
Left high beam high beam
Available power supply (reverse information) F103 10A
Reverse brake control
Reversing lights
Reversing lights
Outer horn
15 pin trailer connector
Left brake lights F104 10A
Right brake lights
15 pin trailer connector
Nitrogen oxide gas concentration sensor F107 10A
AdBlue feed pump module
Engine Water Bypass Solenoid Valve
Air / additional heater F108 20A

The fuse number 14, 15A, is responsible for the cigarette lighter.

Relay designation

After turning on the ignition, the power relay No. 1 R01
After turning on the ignition, the power relay No. 2 R02
After turning on the ignition, the power relay No. 3 R03
Heated and Swing Mirror Power Relay R04
Generator controlled power relay (engine running) R05
Left and right side relay / side and side light power relay R06
Night light relay switches R07
Headlamp high beam relay R08
Alternator Ground Relay (ADR) R09
Auxiliary heater power relay R10
Safety relay and cab tilt enable R11
Right and left side relay / side light and side light power relay (trailer and bodywork) R12
Brake light supply relay R13
High beam relay R14
Wiper Motor Delay Time Relay R15
Power supply relay for automatic transmission ECU R16
Start relay R17
Rear fog lamp power relay R18
Air Suspension Power Relay R19
Power relay for vehicle ECU and engine R20
Accessory Power Relay No. 1 R21
Accessory Power Relay No. 2 R22
Fog lamp power relay R23

Type 2


Photo example.

Diagram
Description
Chronometer F1
Backup power (after starter lock contact) F1
Seven-pin trailer socket (ABS) F1
Power supply of pilot lamps "SERVICE" and "DANGER" F1
Solenoid valve relay "ABS / ASR" (Front left / Rear right) F1
Solenoid valve relay "ABS / ASR" (Front right / Rear left) F1
ABS emergency protection relay F1
Computing device "ABS / ASR" F1
Electric retarder cut-off relay F1
On-board computer F1
Zero speed relay F1
Neutral position relay F1
Parking light, right F2
Side light, right F2
Backup power supply (for lighting) F3
Parking light, left F3
Left side light F3
Power supply for trailer parking lights F4
Backup power supply (for lighting) F5
Instrument panel illumination F6
Illumination of switches F6
Reserve F7
Fog lamp (or lanterns) F8
Fog lights F9
High beam headlamp, right F10
High beam headlamp, left F11
Low beam headlamp, left F12
Low beam headlamp, right F13
Long range floodlights F14
Stroke drive for wipers F15
Electronic tachograph F15
Brake light switch F16
Protection block for transmission "DELTA 2" F16
Reversing lights F16
Daytime running light relay F16
Block of oil level and temperature in the engine cooling circuit F16
Brake lining wear signal relay F16
Power supply of indicator lamps of the instrument panel F16
Defrosting switch for rearview mirrors and windshield F16
Car radio F17
Step-down transformer (telecommunication circuit) F17
Air conditioner circuit F18
Emergency switch “TBV” (RTMDR version) F18
Computing device "TBV" F18
Computing device for automated clutch F18
Air heater (s) F18
Fuel filter heater F19
Turning lights F20
Roof hatch motor F20
Backup power supply (after the general switch) F21
Autonomous heater "D1LC" F22
Autonomous heater "D1LCC" F22
Autonomous heater "Thermo 90" F22
Driver's light F23
Passenger light F23
Lower couch ceiling F23
Upper couch ceiling F23
Footrest lighting F23
Side drawer lighting F23
Motor glass lifter driver F24
Passenger lift glass engine F24
Control tachograph clock F25
Buzzer F26
Stop signal F27
Computing device "ABS / ASR" F28
Defrosting Swivel Mirror, Left F29
Swivel mirror with defrosting, right F29
Time relay for defrosting windshield F29
Power supply of additional elements of the control tachograph F30
Spotlight adjustment drives F30
Heated driver's seat F30
Heated passenger seat F30
Cigarette lighter F30
Step-down transformer (for 12 volt socket) F30
Reserve F31
Wiper drive motor F32
Washer glass pump F32
Headlight washer pump F32
Diagnostic socket F33
Suspension computing device (6 × 2/6 × 4) F33
Interrupter, direction indicator F34
Power supply of the memory of the auto radio receiver F34
On-board computer F34
Autonomous heater "D1LC" F34
Autonomous heater "D1LCC" F34
Programmable auxiliary heater switch F34
Backup power (after starter lock contact) F35
Seven-pin trailer socket (ABS) F36
Electric latch left F37
Electric latch right F37
Reserve F38
Reserve F39
Reserve F40
Reserve F41
Computing device for automated clutch F42
Backup power (for zero speed circuit) F42
Valve illumination F43
Working spotlight (tractor) F43
Radiator grille illumination F43
Trailer power supply + 24 volts F43
Cab tilt pump F44
General electrical switch F45
Centralized lock block F45
Engine heater switch F46
Fuel filter heater switch F46
Speed ​​limiter computing device F46
Dot matrix display F46
Air heater (s) F46
Suspension computing device (4 × 2) F47
Suspension remote control unit F47
Rear axle cushion pressure sensor (6 × 2) F47
Reserve F48
Computing device "ITC" F49

The fuse number 30 is responsible for the cigarette lighter.

Relay modules

  • Power relay after contact RP1
  • Power relay after contact R2
  • Oil pressure switch R4
  • Parking light relay R5
  • Relay for additional comfort elements R6
  • Light relay R8
  • Fog lamp relay R9
  • Fog lamp relay R10
  • Relay for low beam headlights R11
  • Relay for high beam headlights R12
  • Relay for long range floodlights R13
  • Brake light relay R14
  • Relay for solenoid valves "ABS / ASR" (Front right / Rear left) R15
  • Relay for solenoid valves "ABS / ASR" (Front left / Rear right) R16
  • ABS emergency protection relay R17
  • Relay for disconnecting the electric retarder R18
  • Back-up relay R19
  • Relay for defrosting mirrors and windscreen R20
  • Relay for headlights R23
  • Brake lining relay R26
  • Back-up relay R40
  • Fuel heating relay R41
  • Back-up relay R42
  • Back-up relay R44
  • RP45 cab tipping relay
  • Auxiliary heater relay R46
  • Relay for clocking of the headlight washers C753
  • Sound signaling device "EASY" С757

Additional elements

The following relay and fuse elements can be located outside the unit:

  • Auxiliary heater relay
  • Anti-start relay
  • Zero speed relay
  • Neutral position relay
  • Zero speed relay (automated clutch)
  • Emergency protection relay "ITC"
  • Hydraulic retarder cutout relay
  • Daylight relay
  • Windshield defrosting relay (time delayed)
  • Relay starting
  • Engine heater relay
  • 25A Interrupter for direction indicators and alarm
  • 25A Independent heating
  • 25A Onboard radio
  • 25A Alarm
  • 25A Central closing

Block on battery

There may also be a high power fuse block on the battery block cover.

Appointment

FM1 125A Cab power supply
FM2 200A Electric Truck Lift
FM3 125A Engine air intake heater
FM4 40A Reserve
Related fuse diagrams
Comments
Be the first to comment. Nobody responded to this post yet.
Add new comment