Fuses and relays Toyota Aygo (AB10; 2005 - 2014)

The Aygo is a small city car sold by Toyota in Europe. It was first presented at the 2005 Geneva Auto Show. In this material, we will analyze in detail the fuse diagrams for Toyota Aygo (body AB10) 1st generation 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014 release with right and left hand drive.

general view of the car
Here you will find the locations and photos of the fuse blocks. Separately, we note the element responsible for the cigarette lighter.

In the engine compartment

General placement of the electronic components.

1 Engine compartment fuse box
2 Driven anti-skid module
3 Relay unit
4 Left hand drive : Engine control module
5 Left hand drive : Glow plug relay
6 Right hand drive : Glow plug relay
7 Right hand drive : Engine control module

the location of the fuse and relay boxes in the engine compartment
The main fuse box is located near the battery, closer to the windshield. Below the headlamp is the relay box.

Fuse box


Photo - an example of the execution of the main unit.

Diagram
No. Description A
1 EFI 4 - 2WZ-TV: sequential multiport fuel injection system 15
2 H-LP RH (HI) - Up to 2.2012: Right headlamps 10
DRL - From 2.2012: Daytime Running Lamps 5
3 H-LP LH (HI) - Before 2.2012: Left headlamp, sensors and instruments 10
FR FOG - From 2.2012: Front fog lamps 20
4 H-LP RH (LO) - Before 2.2012: Right headlamps 10
H-LP LH - From 2.2012: Left headlamp 10
5 H-LP LH (LO) - Before 2.2012: Left headlamp, sensors and instruments 10
H-LP RH - From 2.2012: Right-hand headlamps 10
6 STA - 1KR-FE: multi-mode manual transmission, sequential multi-point fuel injection system. 7.5
FAN # 2 - 2WZ-TV: cooling fan 7.5
7 EFI # 2 - sequential multiport fuel injection system, multimode manual transmission 7.5
8 EFI # 3 - 2WZ-TV: Multiport Fuel Injection, Cooling Fan. 10
MET - Sensors and meters 5
9 AMT - 1KR-FE: Multi-mode manual transmission 50
RADIATOR FAN - 2WZ-TV: cooling fan 50
10 H-LP LH - Without DRL: Left headlamp 10
Before 2.2012: DIMMER - with DRL: fuses "H-LP LH (HI)", "H-LP RH (HI)", "H-LP LH (LO)", "H-LP RH (LO)" , daytime running light system 10
From 2.2012: SUB-LP - with DRL: fuses "DRL", "FOG FR" 10
11 VSC # 2 - Anti-lock braking system and vehicle stability control system 30
ABS # 2 - without VSC: anti-lock braking system 25
12 AM2 - Starting system, fuses "IG1", "IG2", "STA" 30
13 HAZARD - Direction indicators, emergency flashers, sensors and meters 10
14 H-LP RH - Before 02.2012: Right-hand headlights. 10
H-LP MAIN - From 02.2012: fuses "H-LP LH", "H-LP RH". 20
15 DOME - Gauges and counters, interior lighting, audio system, tachometer. 15
16 EFI - 1KR-FE: Cooling Fan, Distributed Fuel Injection  15
EFI - 2WZ-TV: Cooling Fan, Multiport Fuel Injection  25
17 HORN - Sound Signal 10
18 Spare 7.5
19 Spare 10
20 Spare 15
21 RADIATOR - Tropic: cooling fan 40
RADIATOR - Normal: cooling fan 30
22 VSC1 - Anti-lock braking system and vehicle stability control system 50
ABS1 - without VSC: anti lock braking system 40
23 EMPS - Electric Power Steering 50
24 ALTERNATOR - 1KR-FE: Charging system, "EPS", "ABS (without vehicle stabilization system)", "VSC (with vehicle stabilization system)" , "RADIATOR", "AM1", "HTR", "PWR", " Fuses D / L "," DEF "," TAIL "," STOP "," OBD "," ECU-B " 120
25 EBD resistor
Purpose of relay modules
R1 A / C MAG - Air Conditioning Compressor Clutch
R2 Starter (ST)
R3 Engine control unit (EFI MAIN)
R4 1KR-FE: Toyota Aygo Fuel Pump Relay (C / OPN)
R5 Horn relay
R6 Cooling system fan No. 1

Relay box

Located below the headlamp.

Diagram
No. Relay
R1 Heater PTC1
R2 Heater PTC2
R3 Empty
R4
  • Up to February 2012: Headlamps (H-LP)
  • From February 2012: Daytime Running Lamps (DRL).
R5 Dimer (DIM)
No. Fuse A
1 No -
2 PTC2  -   Heater 80
3 PTC1  -   Heater 80

In the passenger comparment

General placement of the electronic components.

No. Component
1 Power steering control module
2 Center connector
3 Multi-mode manual transmission control module
4 Power window relay
5 Left-hand drive models:
Up to 02.2012: rear light relay
From 02.2012: Rear fog lamp relay.
6 Door control module with receiver
7 Relay block #1
8 Air conditioner amplifier
9 Left hand drive: fog lamp relay
10 Left hand drive: Navigation light relay
11 Fuse box
12 Airbag sensor assembly center
13 Right hand drive: Relay block #2
14 Right-hand drive models
Before 02.2012: Ignition relay (IG)
From 02.2012: Power window relay.
15 Right-hand drive models
Before 02.2012: Power window relay
From 02.2012: Rear fog lamp relay

Fuse box

the location of the fuse box in the psseenger compartment
Cabin fuses are located behind a protective casing in blocks located on both sides of the speedometer. 


To remove the protective box, you need to unscrew the three fastening screws located behind the steering wheel (turn the steering wheel to the sides to get to them with a screwdriver.

Diagram
No. Decryption A
1 STOP - Stop Lamps, high stop Lamp, anti-lock braking system, multimode manual transmission 10
2 Power Door Lock System, Wireless Remote Control System (D / L) 25
3 Heated rear window (DEF) 20
4 Daytime Running Lamp System, Tail Lamps, License Plate Lamps, Side Lamps, Headlamp Level Control, Instrument Panel Illumination (TAIL) 7.5
5 OBD On-Board Diagnostic System 7.5
6 ECU-B - Multi-mode manual transmission, daytime running lamps, vehicle stabilization system, sensors and instruments, rear fog lamp 7.5
7 Empty  
8 ECU-IG - Anti-lock braking system, vehicle stabilization system, electric power steering, cooling fan. 7.5
9 BACK UP - Reversing lights, power door locking system, wireless remote control system, power windows, rear window defogger, tachometer, air conditioning system, heating system 10
10 WIP - Windscreen wiper / washer for windscreen and rear window 20
11 Toyota Aigo Cigarette Lighter Fuse , Power Socket, Audio System ( ACC) 15
12 IG1 - Windshield and rear window wiper / washer, ABS anti-lock braking system, electric power steering, cooling fan, reversing lamps, power door lock system, wireless remote control system, power windows, rear window defroster, tachometer, air conditioning, heating 7.5
13 IG2 - sequential multiport fuel injection system, SRS airbag system, gauges and instruments, daytime running lights, multi-mode manual transmission 15
14 Air Conditioner & Heater - A / C 7.5
15 AM1 - Fuses "ACC", "WIP", "ECU-IG", "BACK UP" 40
16 PWR - power windows 30
17 HTR - heating, air conditioning, fuse "A / C" 40

Relay blocks

Description.

Block #1
R1 Accessories (ACC)
R2 Heater (HTR)
R3 Heated rear window (DEF)
R4 Left hand drive: Ignition (IG)
Block #2
R1 Ignition (IG)
R2 Fog lamps (FOG)
Related fuse diagrams
Comments
Be the first to comment. Nobody responded to this post yet.
Add new comment