Fuses and relays Toyota Celica (T230; 1999-2006)

Unveiled at the January 1999 Detroit Auto Show, the XYR concept car was created at Toyota's Calty Design studio in California. The XYR is the seventh, more stylish generation of the Toyota Celica, born in an atmosphere of changing auto sales market. In this material, we will analyze in detail the fuse circuits of the 7th generation Toyota Celica (T230) 1999, 2000, 2001, 2002, 2003, 2004, 2005, 2006 release.


Here you will find the locations and photos of the fuse blocks. Separately, we note the fuse responsible for the cigarette lighter and fuel pump.

In the engine compartment

General diagram of the electrical equipment.

1 Fuse box
2 Relay box #1
3 '02 -'06: Air Pump Relay
4 '02 -'06: Headlamp Washer Relay
5 Engine control module (M / T) or engine and transmission control module (A / T)
6 '02 -'06: ABS & TRC & VSC (with VSC)
7 Vehicle stability control module (without VSC)
8 '02 -'06: Relay Box # 2


Under the hood is one main fuse box and two additional relay boxes. The second relay block has been installed on cars since 2002.

Main fuse box


Photo - an example of the execution of the main unit.

Diagram
No. Description A
1 S-HTR - '02 -'05: Heated seats 20
AUTO ANTENNA - USA: Antenna 15
2 HEAD LH UPR - High beam left Headlamp 10
3 HEAD RH UPR - High beam right Headlamp (HEAD RH UPR DRL2) 20
4 HEAD LVL - Daytime running lamp, Headlamp range control unit 7.5
DRL3 - Daytime running lights 7.5
5 '99 -'02: Low Beam Right Headlamp 10
'02 -'06: Low beam right Headlamp 15
6 '99 -'02: Low beam left Headlamp 10
'02 -'06: Low beam left Headlamp 15
7 ABS system 25
8 Empty -
9 Empty -
10 Horn 10
11 ALT-S - Charging system 7.5
12 Empty  
13 EFI1 - sequential multiport fuel injection system 10
EFI1 - sequential multiport fuel injection system 7.5
14 DCC - Fuses: "RADIO", "DOME", "MPX-B", "ECU-B" 25
15 Empty  
16 EFI2 - sequential multiport fuel injection system 7.5
10
17 EFI - sequential multiport fuel injection system, fuses: "EFI1", "EFI2" 20
EFI - Europe 2ZZ-GE: sequential multiport fuel injection system, fuses: "EFI1", "EFI2" 15
18 ST - Starting system, sequential multiport fuel injection system 7.5
19 AM2 - Starting system 7.5
20 IG2 - Starting system, sequential multiport fuel injection system 15
21 HAZ hazard warning lights and direction indicators 15
Australia, USA : HAZ hazard warning lights and direction indicators 10
22 HTR - Air conditioner / heater 50
23 Engine cooling fan RDI 30
24 '99 -'02: ABS system 40
'02 -'06: ABS System 50
25 Engine cooling fan CDS 30
26 MAIN - Starting system, daytime running lights, fuse: "ST" 40
MAIN - Europe 2ZZ-GE: Starting system, daytime running lights, fuse: "ST" 50
27 ALT - Cooling system, engine cooling fan, starting system, rear window heating, side light, fuses: "ABS NO.1", "ABS NO.2", "HTR", "FR P / W", "FL P / W ”,“ DOOR ”,“ OBD ”,“ STOP ”,“ S / ROOF ”,“ MIR HTR ”,“ FR FOG ”,“ AM1 ” 120
28 Throttle body ETCS 10
29 Air pump A-PMP 50
30 CLN H-LP - Headlight washers 30/50
Purpose of relay modules
R1 Horn
R2 Headlamps (HEAD)
R3 Toyota Celica Fuel Pump Relay (C / OPN)
R4 Engine control unit (EFI)
R5 Engine cooling fan (FAN1)
R6 Ignition (IG2)
R7 Engine cooling fan (FAN2 / FAN3)
R8
R9 A / C compressor relay (MG / C)
R10 Starter (ST)
R11 Heater (HTR)
R12 ABS SOL
R13 ABS motor

Relay blocks

Diagrams.

Block #1
R1 Daytime Running Lamps
R2
R3 Daytime running Lamps(DRL2 - DIMMER)
1 High beam - left 10A
2 High beam - right, daytime running lamps 10A
Block #2 (2002 - 2006)
1 VSC - 10A 
R1 VSC MTR
R2 MTR CUT
R3 VSC SOL

In the passenger compartment

General diagram of the electrical equipment.

1 Rear fog lamp relay
2 Hazard and turn signal lamps relays
3 Front fog lamp relay
4 '02 -'06: Headlamp leveling control module
5 '02 -'06: Vehicle stability control module
6 '99 -'02 (LHD): ABS Control Module
7 Air conditioner control module
8 Fuse box
9 Body ECU
10 '02 -'06: Heated Seat Relay
11 Airbag control module
12 Key transponder amplifier
13 '02 -'06 (Australia): Headlight range control module
'99 -'02 (RHD): ABS Control Module
14 14. '02 -'06 (RHD): Headlight range control module
15 15. '02 -'06 (Australia): Cruise Control Module
16 16. '02 -'06 (Australia): Gear selector lock control module


Located on the passenger side (left-hand drive models), or on the driver's side (right-hand drive models), at the bottom left behind the protective cover.


General view of the block.

Toyota Celica T230 interior fuse box diagram
No. Description A
1 Sunroof (S / ROOF) 15
2 Power windows (FL P / W) 20
3 Stop lamps, ABS, auxiliary brake lamp, multiport fuel injection system / sequential multiport fuel injection system, automatic transmission control unit, cruise control (STOP) 10
4 Airbags (SRS-IG) 7.5
5 Windshield washer, rear window washer (WASHER) 15
6 Audio system (RADIO) 15
7 Direction indicators (TURN) 7.5
8 Air conditioner (HTR) 10
9 Parking Lamps, Instrument Panel Lights, License Plate Lights (TAIL) 10
10 CIG - Toyota Celica Cigarette Lighter Fuse (T23) 15
11 AM1 - Starting system, fuses: "CIG", "ECU ACC", "SRS − IG", "WASHER", "WIPER", "BK / UP LP", "TENS RDC", "DEF RLY", "BODY ECU −IG "," TURN "," HTR "," WARNING "," FAN RLY "," ABS − IG "," ECU − IG " 25
12 DOOR - Central locking 20
13 Front fog lamps (FR FOG) 15
14 OBD diagnostic connector 7.5
15 Front wiper 25
16 MIR HTR - Heated mirrors 10
17 Rear wiper - RR WIPER 15
18 FR P / W - Power Windows 20
19 Heated rear window (DEF) 30
A line
1 MPX-B - Remote door lock control system 7.5
2 Rear fog lamps (RR FOG) 7.5
3 Clock, interior lamps (DOME) 7.5
4 Air conditioning, instrument cluster (ECU-B) 7.5
B line
1 Charging system, instrument cluster (WARNING) 5
Cruise control (ECU-IG) 5
3 ABS-IG - ABS system 5
4 Engine cooling fan (FAN RLY) 5
C line
1 Glove compartment lighting, instrument panel lighting (PANEL 1) 7.5
2 Front fog lamps, instrument cluster illumination (PANEL 2) 7.5
3 Clock, audio system, mirror control module, antenna (ECU-ACC) 7.5
4 Empty -
D line
1 Reversing lamps (BK / UP LP) 5
2 Heated rear window, heated mirrors (DEF RLY) 5
3 Multiplex module (BODY ECU-IG) 5
4 TENS RDC - Automatic Transmission Control Module, Transmission Selector Lock, Sunroof, Aerial 5
Purpose of relay modules
R1 Ignition (IG1)
R2 Tail lamps (TAIL)
R3 Heated mirrors (MIR HTR) / heater
R4 Heated rear window (DEF)

Car body


Location of components

  1. Sunroof relay (if equipped),
  2. Rear wiper relay,
  3. Central locking receiver
Similar cars
Add new comment