Fuses and relays Volkswagen Caravelle / Multivan (T5), 2002 - 2015

Volkswagen Caravelle and Multivan are very similar both technically and externally. Their main difference between themselves is the interior trim and panels. Both of these models are released on the same base with the wv transporter and represent its passenger version. In this publication you will find a description of the fuse boxes and relays of the Volkswagen Karavella (Multiven) T5. Years of manufacture of the fifth generation (T5): 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015. We will also show the location of all control units, a video example of finding exactly the fuse and relay blocks, as well as their photos and diagrams. We will pay special attention to the fuses responsible for the cigarette lighter for both generations.

Due to the wide variety of equipment options and the length of the body base, there is no one general description of the purpose of all elements. We will show the most common ones. In case of difficulty, check the designation with yours, on the back of the protective cover or instructions, or contact your nearest dealer.

General arrangement of control units
Designation
1 ABS electronic control unit
2 Air conditioning control unit - in the heater control panel
3 Air conditioning control unit (rear) - in the heater control panel
4 Antenna unit - if available
5 Side impact sensor, driver's side
6 Side impact sensor, rear left
7 Side impact sensor, passenger side
8 Side impact sensor, rear right
9 Anti-theft control unit
10 Anti-theft alarm horn - intake system resonator
11 Audio Output Amplifier - Under Front Right Seat - If Equipped
12 Additional battery 1 - under the front left seat - if equipped
13 Extra Battery 2 (RV) - in the kitchen cabinet
14 Additional heater control unit (Air Top 3500) - under the body bottom, on the right - if available
15 Additional heater control unit (Thermo Tor) - under the body bottom, on the left - if any
16 Accumulator battery
17 Camping equipment control unit (RV)
18 Diagnostic connector (DLC)
19 Diagnostic unit - instrument panel
20 Driver's door control unit
21 Rear left door electrical control unit (with electric sliding door) - LH pillar
22 Passenger door electronics control unit
23 Rear right door electrical control unit (with electric sliding door) - right pillar
24 ESP stability control unit (includes acceleration sensor, lateral movement sensor)
25 Roof lift control unit (RV)
26 ECM - near engine fuse / relay box 1
27 Cooling Fan Motor Control Module 1 - Suspension (Front Left)
28 Cooling fan motor control unit 2 - in the cooling fan motor 2 - if installed
29 Fuse / relay box, engine compartment 1
30 Fuse / relay box, engine compartment 2
31 Fuse / relay box, engine compartment Z
32 Fuse / Relay Box, Instrument Panel 1 - Center of Instrument Panel
33 Fuse / relay box 2, dash - under dash fuse / relay box 1
34 Fuse / relay box, instrument cluster 3 - behind the fuse / relay box, instrument cluster 1/2
35 Fuse / relay box, instrument panel 4 - behind the fuse / relay box, instrument panel 1/2
36 Fuse / Relay Box, Left Seat - Under Seat
37 Additional fuse 1 (differential lock switch, rear 10A) - left front pillar
38 Additional fuse 2 (additional heater 30A) - under the left seat
39 Additional fuse 3 (door electronics control unit, left rear 40A) - under the left seat (some models)
40 Heater blower motor resistor 1 - near the rear heater blower motor
41 Heater blower motor resistor 2 - near the rear heater blower motor - if equipped
42 Beep 1
43 Sound signal 2 - if available
44 Immobilizer Control Unit - Instrument Cluster
45 Immobilizer ring antenna - near the ignition switch
46 Instrument Cluster Control Unit - Instrument Panel
47 Telephone control unit - behind the glove box
48 Multifunction control unit 1 - functions: Automatic transmission (automatic transmission), charging system (with additional battery), cruise control, door / bonnet switch contact recognition, electrical load control, power windows, fuel pump, headlight washers, rear mirror heater door views, rear window defroster, hazard warning lights, windshield defroster, horn, direction indicators, instrument cluster illumination, interior lamps, automatic wipers, reversing lights, starter, sunroof, light switch, windshield washer, wiper windshield
49 Multifunctional control unit 2 - functions: Anti-theft system, central locking, power door mirrors, power sliding door, power windows, sunroof
50 Navigation control unit - in navigation display
51 Ambient temperature sensor
52 Parking system control unit
53 Driver's seat heating control unit
54 Seat heating control unit, passenger
55 Steering Wheel Position Sensor - If Equipped
56 Sunroof electric control unit
57 SRS electronic control unit
58 Rear door open / close drive control unit - left "D" pillar - if equipped
59 Traffic information control unit - under dash
60 Traffic information control unit (alternative position) - under the dashboard
61 Transfer case control unit (with 4WD) - rear final drive
62 Electronic transmission control unit (automatic transmission) - near the engine control unit
63 Voice synthesizer - under the front right seat - if equipped
64 Vehicle speed sensor - gearbox (some models)

Under the hood

Main fuse box


photo

Diagram
Amps / Description
1 (5A) Cooling fan (s) motor (s)
2 (5A) Coolant pump relay
3 (15A) Air conditioning (5A) Crankcase ventilation resistor
4 (30A) Anti-lock braking system (ABS) or Voltage stabilizer, Stereo, Radio
5 (15A) Automatic transmission
6 (30A) Anti-lock braking system (ABS)
7 (5A) Cooling fan motor control unit 1 (7.5A) Washer pump
8 (15A) Engine management
9 (5A) Engine management, main ignition circuit relay
10 (5A) Engine management (15A) Charge or exhaust valve
11 (5A) Power steering control unit (30A) Headlamp switch and headlight relay
12 (5A) Engine management (10A) Fuel pressure regulator
13 (10A) Engine management (10A) Xenon in the left headlight
14 (5A) Engine management or fuel pump relay
15 (10A) Reversing light switch
16 (5A) Engine management or brake light switch, air mass meter
17 (5A) Anti-lock braking system (ABS)
18 (5A) Power steering
19 (5A) Brake light switch (brake pedal position sensor), clutch pedal position sensor
20 (5A) Engine management
21 (5A) Exhaust gas recirculation valve
22 (10A) Engine management (injectors)
23 (25A) Automatic transmission (10A) Xenon headlight right
24 (5A) Automatic transmission
25 (25A) Engine management, Ignition
26 (25A) Engine management (5A) LH headlight
27 (5A) Coolant pump relay
28 (15A) High tone signal
29 (10A) Vehicle speed sensor (5A) Right headlight
30 (15 / 20A) A / C / heater auxiliary pump relay, fuel pump, fuel pump relay
31 (15A) Engine management (lambda probe)
32 (30A) Engine management (ignition) (5A) Fuel pump relay
33 (5A) Coolant pump relay engine management, glow plug relay
34 (10A) Cooling fan motor control unit (5A) Bot network control unit
35 (10A) Engine management (15A) Fuel level regulator
36 (25A / 30A) Starter relay (5A) Data bus interface

High power fuse box

Located next to the assembly and connected to the battery.

Photo diagram
Amps / Description
1 (175 / 225A) Generator
2 (125A) Battery power distribution, auxiliary ignition relay, driver's door control unit, passenger door control unit, rear window defroster, terminal X relay, separate fuses
3 (50A / 100A) Charging system (with additional battery), rear left door electrical control unit (some models), rear right door electrical control unit (some models), relay - divider in the charging system (with additional battery)
4 (125A) Battery power distribution (70A) Positive connection in engine compartment wiring harness
5 (50A) Battery power distribution (some models), separate fuses
6 (60A) Glow plug relay (50A) Exhaust air pump motor
7 (70/80 / 100A) Cooling fan (s) motor
8 (40/50 / 100A) Cooling fan (s) motor, separate fuses
9 (100A) Battery power distribution, ignition switch
10 -

Relay box


Also located next to the fuse box.

Diagram
Description
Type 1
1 Air conditioning electronic control unit (manual temperature control)
2 Fuel pump relay 2
3 Outlet air pump relay
4 Relay for main ignition circuits
5 Fuel pump relay 1
6 A / C compressor electromagnetic clutch relay (automatic temperature control)
7 Automatic transmission control relay
8 Power steering control unit
9 Coolant pump relay
Type 2
1 Air conditioning electronic control unit (manual temperature control)
2 Fuel pump relay 2
3 Outlet air pump relay
4 Relay for main ignition circuits
5 Fuel pump relay 1
6 A / C compressor electromagnetic clutch relay (automatic temperature control)
7 -
8 Coolant pump relay
9 Starter relay - if equipped

In the cabin

Main fuse box


Photo

Upper section diagram
Amps / Legend
1 (25A / 30A) Heater, air conditioner, terminal 15 power relay
2 (5A) Steering wheel position sensor
3 (10A) Multifunction control module 1 (onboard supply)
4 (10A) Headlight range control (5A) Lane change assist
5 (15A) Left headlight bulb
6 (15A) Left headlight bulb
7 (15A) Multifunction control module 1 (interior lamp or vehicle electrical system)
8 (5A) Diagnostic connector (DLC) (15 / 20A) sliding roof and door control unit, tailgate
9 (15A) Brake light switch (brake pedal position sensor) (30A) Onboard supply control unit
10 (10A) Windshield wiper, rear window wiper
11 (5A) License plate lamp
12 (15A) Cigarette lighter (5 / 30A) Light switch
13 (5 / 10A) SRS electronic control unit
14 (30A) Auxiliary heater heater, air conditioning (25A) Headlight switch
15 (7.5) Air conditioning (fan switch and relay)
16 (5A) Multifunction control module
17 (5A) Rear fog lamps, instrument cluster
18 (5A) Instrument cluster control module
19 (5A) Audio system, instrument cluster control unit, multifunction control unit 1, navigation system, special vehicle equipment
20 (5A) Front left-hand, left-hand brake light, tail-light-left, or differential lock
21 (5A) Front light RH, brake light RH, tail light RH or starter relay, ECM
22 (7.5 / 10A) Passenger airbag deactivation indicator, diagnostic connector (DLC), instrument cluster control unit
23 (5 / 30A) Starter relay (some models with manual transmission)
24 (5A) Steering wheel position sensor
25 (7.5A) Air conditioner (fans)
26 (30A) Headlamp switch
27 (15A) Right headlight bulb
28 (15A) Headlamp high beam indicator, right headlight
29 (10A) Tailgate signal relay
30 (10A) Heated windscreen washer nozzles, rear window wiper motor
31 (30A) Multifunction control module 1 (horn)
32 (25 / 30A) Multifunction control module 1 (windscreen wiper motor)
33 (15A) Audio system, navigation system, traffic information control module
34 (25A) Automatic transmission control system, fuse / relay box, engine compartment 1
35 (5A) Instrument cluster illumination
36 (25A) Multifunction control module 1 (direction indicators)
According to the diagram, fuse number 12 is responsible for the VW Caravelle / Multivan cigarette lighter.
Lower section diagram
Amps / legend
1 (25A) Trailer electrical connector (15A) 10-pin connector
2 (5A) Anti-theft system
3 (5A) Heater air conditioner auxiliary fan, left and right (10 / 15A) Optional equipment
4 (10A) Transfer case control module (differential)
5 (10A) Accessory connector or 6-pin connector
6 (5A) Engine oil condition sensor (level, temperature)
7 (10A) Roof fan (30A) Anti-theft alarm
8 (5A) Parking system
9 (5A) Steering column control module (cruise control)
10 (30A) Audio system (10A) Headlight range control, instrument lighting level
11 (20A) Anti-theft alarm horn, multifunction control module 2, power sliding door, tailgate opener control module (15A) Walkie-talkie, anti-theft system
12 (5A) LH headlight (10A) Brake light off relay (30A) Onboard power supply control
13 (5A) Cruise control main switch, multifunction steering wheel control
14 (5A) Telephone, RH headlight (30A) Onboard power supply management
15 (5A) Automatic transmission or Telephone and voice control
16 (5A) Audio system navigation, telephone (7.5A) TV tuner
17 (7.5A) Multifunction control module (interior lamp, dimmable mirror)
18 (5A) Air conditioner (some models)
19 (5A) Auto dimming interior rearview mirror
20 (10A) Multifunction control module 1 (heated door mirrors)
21 (5A) Anti-theft system or rain sensor
22 (5A) Air conditioning or pressure sensor
23 (5A) Auxiliary heater and accessories
24 (7.5A) Interior lamps
25 (15A / 25A) Heated seats
26 (10A) Tachograph (if equipped)
27 (15A) Fog lights or power supply relay
28 (5A) Rearview mirror adjustment switch, door mirror heaters
29 (25A) Auxiliary heater
30 (5A) Auxiliary heater
31 (25A) Hatch (5A) Onboard charger
32 (20A) Headlamp washers and its relay
33 (5A) Tachograph (if equipped)
34 (15A) Auxiliary power supply connector 3 (rear) (5A) Multifunction steering wheel control module
35 (10A) Multifunction control unit 1 (reversing light (s), with automatic transmission) (20A) Onboard supply control unit
36 (5A) Camping equipment control unit, special vehicle equipment

Relay box behind the main fuse boxes

Diagram
Type 1
Legend
1 -
2 Relay 1 auxiliary heater
3 A / C blower motor relay, rear
4 Relay for auxiliary ignition circuits
5 - 06/03: Rotating beacon relay (special purpose vehicle)
6 Brake light cut-off relay
7 Headlight washer pump relay
8 A / C / heater auxiliary pump relay
F1 -
F2 (30A) Door control module (driver), door control module (passenger)
F3 (40A) Heated rear window
Type 2
Legend
1 A / C blower motor relay, rear (some models)
2 Steering column electronics control unit
3 Steering column electronics control unit
4 Roof fan relay 1
5 Differential lock control unit
6 06/03: Tailgate signal relay
F1 (15A) Siren (special purpose vehicle)
F2 (10A) Siren (special purpose vehicle)
F3 (10A) Rotating beacon (special vehicle)
F4 (40A) Rear left door control module (ECM)
F5 (40A) 01/04: Right rear door control module
F6 (5A) 01/04: Voice synthesizer (if available)

Block under the driver's seat

Diagram
Type 1
Legend
1 Relay - divider in the charging system (with additional battery)
2 -
3 Relay - divider in the charging system (with additional battery)
4 Special vehicle equipment
5 Special vehicle equipment
F1 (5A) Camping equipment control box
F2 (10A) Accessory Power Socket 1 (Front), Refrigerator (RV)
F3 (5A) Fresh water pump (camper)
F4 (10A) Interior lamps, local lighting (commercial vehicle)
F5 (30A) Bodywork power connector control module (commercial vehicle)
F6 (40A) Roof lift control module (commercial vehicle)
F7 (5A) Antenna unit
F8 (25A) Additional heater
F9 (30A) Heater air conditioner blower motor (automatic temperature control)
F10 -
F11 -
F12 -
F13 (40A) Rear right door control module
F14 (80A) Additional battery
Type 2
Description
1 -
2 Relay-divider in the charging system (with additional battery)
3 Special vehicle equipment
4 Special vehicle equipment
5 Special vehicle equipment
F1 (15A) Accessory power connector (s)
F2 (15A) Accessory power connector (s)
F3 (15A) Accessory power connector (s)
F4 (15A) Refrigerator (RV), special vehicle equipment
F5 (5A) Antenna unit
F6 (25A) Additional heater
F7 (30A) Air conditioner / heater blower motor (automatic temperature control)
F8 -
F9 -
F10 -
F11 (40A) Rear right door control module
F12 (80A) Additional battery
Type 3
Legend
1 5A - 10-pin connector / 6-pin connector
2 3A - 10-pin connector
3 5 / 15A - 10-pin connector or emergency data logger
4 15A - 10-pin connector
5 5A - 10-pin connector
6 25A - 6-pin connector
7 15/30 - 12V socket, voltage converter
8 20 / 25A - Heater (heater) control unit
9 25 / 30A - Supply fan
10 15 / 30A - Climate control
11 15A - Cigarette lighter
12 5A - 10-pin connector / 6-pin connector
13 Local relay
14 Local relay
15 Local relay
16 30A - On-board charger
17 30A - Roof hydraulics control unit
18 10A - Lighting plafonds
19 10A - Cooled compartment
20 5A - Water pump
21 5A - Camper equipment control panel
21 15A - 12V socket
22 15A - 12V socket
23 10A - Roof fan or 12V socket
24 15A - Trailer recognition control unit
25 20A - Trailer recognition control unit
26 20A - Trailer recognition control unit
27 7.5A - Trailer recognition control unit
28 Reserve
29 5A - Voice amplifier control unit
30 Reserve
31 Reserve
32 15A - Lumbar support for the driver's seat
33 40A - Right sliding door control unit
34 80A - Control unit for charging the second battery
35 40A - Left sliding door control unit
36 40A - Supply fan
37 6-pin connector
38 Reserve
Related materials
Add new comment