Table of Contents
The S60 sedan, introduced in 2000, occupies a junior position to the S80. It is based on the same Volvo-developed platform, adapted for front- or all-wheel drive versions. The manufacturer emphasized a radical change in the image of its new models compared to previous Volvo models. In this article we will understand in detail fuse box diagram Volvo S60 (1Gen; RS, RH body) 2000, 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009 years of manufacture.
Here you will find the locations and photos of the mounting blocks. Also, we will separately mark the fuses responsible for the cigarette lighter and the fuel pump.
The fuse boxes located in the luggage and engine compartments are similar to the XC90, so if you are interested in the items located in them, read this material.
In the passenger compartment
Located on the driver's side at the end of the dashboard.
General view of the Volvo S60 interior fuse box.
| Diagram | ||
|---|---|---|
|
||
| № | A | Description |
| 1 | 10 | 2000-2002: Headlight dipped beam, left side |
| 15 | 2003-2004: Low beam, Bi-Xenon | |
| 25 | 2005-2009: Power driver's seat | |
| 2 | 10 | 2000-2002: Headlight dipped beam, right-hand side |
| 20 | 2003-2004: High beam | |
| 25 | 2005-2009: Power Passenger Seat | |
| 3 | 15 | 2000-2002: Dipped beam |
| 30 | 2003-2004: Power Driver Seat | |
| 2005-2009: Air conditioner fan | ||
| 4 | 20 | 2000-2002: High beam |
| 30 | 2003-2004: Power Passenger Seat | |
| 25 | 2005-2009: Right control unit, front door | |
| 5 | 30 | 2000-2002: Power driver's seat |
| 15 | 2003-2004: Power steering, vacuum pump | |
| 25 | 2005-2009: Control unit, left, front door | |
| 6 | 30 | 2000-2002: Power Passenger Seat |
| 5 | 2004; Bi-Fuel: Gas cylinder valve | |
| 10 | 2005-2009: General lighting, overhead (RCM), overhead electronic control unit (UEM) | |
| 7 | 15 | 2000-2004: Heated Seat (Front Left) |
| 2005-2009: Sunroof | ||
| 8 | 15 | 2000-2004: Heated Seat (Front Right) |
| 7.5 | 2005-2009: Ignition switch, SRS system, engine control module (ECM), passenger side SRS shutdown (PACOS), electronic start interlock (IMMO), transmission control module (TCM; diesel and R-models for 2006) | |
| 9 | 5 | 2000-2004: ABS / STC (2003-2004) / DSTC (2003-2004) |
| 2005-2009: OBDII, light switch (LSM), steering angle sensor (SAS), steering wheel control module (SWM) | ||
| 10 | 15 | 2000-2002: High beam headlights, left |
| 20 | 2005-2009: Audio | |
| 11 | 15 | 2000-2002: High beam headlights, right |
| 30 | 2005-2009: Audio system amplifier | |
| 12 | 15 | 2000-2004: Headlight corrector (2004), headlight cleaners |
| 10 | 2005-2009: RTI display | |
| 13 | 20 | 2000-2002: 12V socket / cigarette lighter fuses |
| 15 | 2003-2004: 12V socket / cigarette lighter | |
| 5 | 2005-2009: Phone | |
| 2005-2009: No. 14-38 - Not used | ||
| 14 | 5 | Power Passenger Seat, Front Seat Belts (2000-2002) |
| 15 | 5 | 2000-2003: Audio, VNS |
| 2004: Audio RTI | ||
| 16 | 20 | Audio |
| 17 | 30 | Amplifier |
| 18 | 5 | 2000-2002: Front fog lamps |
| 15 | 2003-2004: Front fog lamps | |
| 19 | 10 | 2000-2003: VNS |
| 2004: RTI display | ||
| 20 | 5 | 2002: Transport switch |
| 21 | 10 | Automatic transmission, transmission selector lock, D2 |
| 22 | 20 | Direction indicators |
| 23 | 5 | Light switch, diagnostic connector, steering wheel module, climate control / comfort unit |
| 24 | 10 | 2000-2002: Climate control unit, power driver's seat, instrument cluster |
| 2003-2004: Climate control unit, power driver's seat, instrument cluster, parking heater | ||
| 25 | 10 | 2000-2002: Ignition switch, central electronic module, starter relay |
| 2003: Ignition Switch, SRS, Starter Relay, ECM | ||
| 2004: Ignition switch, central electronic module, starter relay, engine control unit | ||
| 26 | 30 | Air conditioner control unit |
| 27 | 15 | 2000-2002: Front door electronics module |
| 2004: Active chassis FOUR-C | ||
| 28 | 10 | Ceiling module, interior lighting |
| 29 | 10 | Telephone |
| 30 | 10 | 2000-2002: Position lamps (left) |
| 7.5 | 2003-2004: Position lamps (left) | |
| 31 | 10 | 2000-2002: Position lamps (right), license plate illumination |
| 7.5 | 2003-2004: Position lamps (right), license plate illumination | |
| 32 | 10 | Central electronic module, illuminated visor mirror, power steering, glove box lighting (2003-2004), interior lighting (2003) |
| 33 | 15 | Fuel pump fuse Volvo S60 |
| 34 | 15 | Sunroof |
| 35 | 25 | Central locking, power windows, left power mirror |
| 36 | 25 | Central locking, power windows, power right mirror |
| 37 | 30 | Rear windows, child lock (2003-2004) |
| 38 | 5 | 2003-2004: Anti-theft system siren |
All electrical equipment
General layout of the electronic modules in the vehicle.
|
|
| No. | Component |
| 1 | air conditioner ECU |
| 2 | Air conditioning / heater fan control module - next to the fan motor |
| 3 | Vehicle tilt sensor (anti-theft system) |
| 4 | Anti-theft alarm horn behind the front right wheel arch trim |
| 5 | Volume change sensor (anti-theft system) - ceiling panel |
| 6 | Anti-theft alarm sensor - in the multifunction control unit |
| 7 | Audio ECU |
| 8 | Additional heater control module, if installed |
| 9 | Battery - under the boot floor |
| 10 | Cruise control module built into the ECM. |
| 11 | Diagnostic connector (DLC) |
| 12 | Differential Lock Control Module - Rear Differential (4 × 4) |
| 13 | Driver's door electrical control module -in door- functions: Central locking, open or not tightly closed door indicators, power/heated door mirrors, power windows, light bulbs in door mirrors |
| 14 | Passenger door electrical control module -in door- functions: Central locking, open or loose door indicators, power/heated door mirrors, power windows, light bulbs in door mirrors |
| 15 | Cooling Fan Motor Control Module |
| 16 | Fuse box, engine compartment 1 |
| 17 | Fuse block 2 engine compartment - under block 1 of the engine compartment |
| 18 | Fuse box, passenger compartment 1 |
| 19 | Fuse box, passenger compartment 2 |
| 20 | Fuse box, trunk 1 |
| 21 | Luggage compartment fuse box 2 - next to the battery |
| 22 | Headlamp control module, left (xenon headlamp models) |
| 23 | Headlamp control module, right (xenon headlamp models) |
| 24 | Horn (beep) |
| 25 | Immobilizer - in ECU by engine |
| 26 | Immobilizer ring antenna - near the ignition switch |
| 27 | Instrument Cluster Control Module - Instrument Cluster |
| 28 | Lighting control module - behind the headlight switch |
| 29 | Multifunction control unit - connected to fuse box No. 2 in the passenger compartment - functions: Anti-theft system, central locking, power windows, windshield wiper/washer, headlight wiper/washer, power steering, immobilizer, headlights, turn signal/emergency lights, horn, front/rear parking lights, starter, heated seats. Headlight corrector, fuel pump, duffel box light bulb, center brake light. |
| 30 | Multifunction control box 2-connected to fuse box , luggage compartment No. 1 - functions: Anti-theft system, central locking, tail lights, fuel gauge, interior lamps, rear window heater, accessory power connector - rear, fuel filter heater - Diesel, rear seat head restraints. |
| 31 | Multifunction control unit 3 - in the interior rearview mirror - functions: Central locking, anti-theft system, sunroof, rain sensor, interior lamps, not fastened seat belt reminder |
| 32 | Navigation control module |
| 33 | Ambient air temperature sensor - in the mirror of the right door |
| 34 | Rain sensor (availability depends on equipment) |
| 35 | Relay for door locking system against accidental opening, left. - in the door |
| 36 | Relay for door locking system against accidental opening, right . - in the door |
| 37 | Power Seat Control Module - Under Seat, Driver's Side |
| 38 | Side impact sensor, front left - B-pillar |
| 39 | Side impact sensor, front right - B-pillar |
| 40 | Side impact sensor, rear left - behind the rear seat cushion support |
| 41 | Side impact sensor, rear right - behind the rear seat cushion support |
| 42 | SRS ECU |
| 43 | Steering Wheel Position Sensor Module - Connected to under-dash fuse box # 2 |
| 44 | Steering wheel electrical control module - behind the steering wheel - functions: Audio system, speed maintaining system (cruise control),horn, turn signal, turn indicators, windshield wiper/washer, low beam/distance beam, trip computer |
| 45 | Sunroof control module |
| 46 | Suspension control module - side of center console |
| 47 | Transmission ECU |
| 48 | Gear Shift Control Module |
| 49 | Telematics unit |
