Fuses and relays Volvo XC60 (DZ; 2008 - 2017)

Volvo's new SUV was built on the same platform as the Ford Mondeo and Land Rover Freelander. He made his debut in 2008 and became the first car of the updated "60" line: after him in 2010, the fresh S60 and V60 appeared. In this material, we will analyze in detail the fuse diagrams of the second generation Volvo XC60 (DZ series body): 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015, 2016, 2017 release.


Here you will find the locations and photos of the fuse blocks. Separately, we note the elements responsible for the cigarette lighter and fuel pump.

In the passenger compartment


The fuse box is located under the glove compartment. Its execution depends on the year of manufacture of the car. In models from 2010, it consists of two boards, in earlier versions it consists of one.


Example of access to board A (Volvo XC60 from 2010).

Diagram (Volvo XC60 2011-2017 release)
Board "A"
No. A Description
1 40 Audio control module main fuse *; primary fuse for fuses 16-20; infotainment system
2 25 From 2014: Windshield washers; rear window washer
3 - Spare
4 - Spare
5 - Spare
6 - Spare
7 15 12V socket in cargo area
8 20 Control panel, driver's door
9 20 Control panel, front passenger door
10 20 Control panel, rear right passenger door
11 20 Control panel, rear left passenger door
12 20 Keyless entry system 
13 20 Power driver's seat
14 20 Electric passenger seat
15 15 2011-2012: Folding headrest 
2013-2017: Spare
16 5 2011: Spare 
2012-2017: Information system module or monitor
17 10 Audio system module (amplifiers); TV; digital radio
18 15 Audio system module or Sensus control module
19 5 Telematics; Bluetooth
20 - Spare
21 5 Panoramic roof with sun blind; interior ceiling lighting; air conditioner sensor
22 15 2011: Volvo XC60 cigarette lighter fuse, Rear Seat Entertainment (RSE)
2012-2017: 12V socket in tunnel console
23 15 2011: Seat heating, passenger side
2012-2017: Heated rear right seat
24 15 2011: Seat heating, driver's side
2012-2017: Heated rear left seat
25 - Spare
26 15 2011: Heated rear right seat
2012-2017: Heated front passenger seat
27 15 2011: Heated rear left seat
2012-2017: Heated driver's seat
28 5 Parking assistance; Parking camera; BLIS; RTi
29 10 2011-2012: AWD control unit
15 2013-2017: AWD control unit
30 10 Active chassis Four-C
Board "B"
No. A Appointment
1 15 Rear window wiper
2 - Spare
3 7.5 Interior lighting; power window control panel on the driver's door; electric seats
4 5 Combined device
5 10 Adaptive cruise control, ACC *; collision warning
6 7.5 Interior lighting; Rain sensor
7 7.5 Rudder module
8 10 Central locking, fuel filler cap
9 15 2011-2013: Rear window washer
2014-2017: Heated steering wheel
10 15 2011-2013: Windshield washers
2014-2017: Heated windshield
11 10 Unlocking the tailgate
12 10 2011: Tailgate lock
2012: Spare
2013-2017: Folding headrest
13 20 Fuel pump fuse
14 5 Anti-theft alarm motion sensor; micro climate panel
15 15 Steering wheel lock
16 5 Security alarm siren; OBDII diagnostic socket
17 - Spare
18 10 Airbag City Safety
19 5 Collision warning system
20 7.5 Gas pedal position sensor; anti-glare function of the interior rear-view mirror; heated rear seat; additional electric heater
21 15 Infotainment control module (Performance); audio system (Performance)
22 5 Brake light
23 20 Panoramic roof with sun blind
24 5 Start blocking
Diagram for models up to 2010
No. A Description
1 5 Rain sensor
2 10 SRS system
3 5 ABS brakes
4 7.5 Gas pedal, air heater (RTS), heated seats
5 - Empty
6 15 ICM display, CD and Radio, RSE system
7 7.5 Steering wheel module
8 - Empty
9 15 High beam
10 20 Sunroof
11 7.5 Reversing lights
12 - Empty
13 15 Fog light in front
14 15 Windshield washers
15 10 Adaptive cruise control, ACC
16 - Empty
17 7.5 Roof lighting, control panel in driver's / passenger's door with electric drive
18 5 Information display
19 5 Power driver's seat
20 15 Rear window wiper
21 5 Remote Key Receiver, Alarm System Sensors
22 20 Gasoline pump Volvo XC60
23 20 Electric steering lock
24 - Empty
25 10 Fuel tank / tailgate lock
26 5 Alarm siren, ECC
27 5 Start / stop button
28 5 Brake light switch

In the engine compartment


The main fuse box is located on the left side behind the protective cover. It consists of three sections.


Photo is an example.

Diagram
No. A Description
R1 - Starter relay
R2 - Engine control relay
R3 - A / C compressor electromagnetic clutch relay
R4 - Fuel filter heater relay
1 50 Main fuse for the central electronic module (CEM) with fuse box B under the glove compartment
2 50 Main fuse for the central electronic module (CEM) with fuse box B under the glove compartment
3 60 Main fuse for the load compartment fuse box
4 60 Main fuse for the electrical distribution box in the passenger compartment with fuse box A under the glove compartment
5 50  1) Main fuse for the electrical distribution box in the passenger compartment with fuse box A under the glove compartment
60
6 - Spare
7 100 RTS Air preheater
8 20 2008-2011: Spare
2012-2013: Headlight washers
40 2014-2017: Heated windscreen, left side
9 30 Windshield wiper
10 25 Parking heater
11 40 Interior fan
12 40 2008-2013: Spare
2014-2017: Heated windscreen, left side
13 40 ABS pump
14 20 ABS valves
15 20 2008-2013: Spare
2014-2017: Headlight washers
16 10 Headlamp leveling: active xenon headlights - ABL
17 20 Primary fuse for the central electronic module (CEM) with fuse box B under the glove compartment
18 5 2008-2010: Radar sensor, ACC control module
2011-2017: ABS
19 5 Speed-adaptive power steering
20 10 Engine control module, transmission control module, airbags
21 10 Heated washer nozzles
22 - Spare
23 5 Light control knob (lighting panel)
24 15 2008-2010: Headlight washers
2011-2017: Spare
25 15 2008-2010: Front and rear seat 12V electrical socket ( cigarette lighter )
2011-2017: Spare
26 5 2008-2010: Sunroof, roof console / ECC
2011-2017: Spare
27 5 2008-2013: Relay, engine compartment unit
2014-2017: Washer relay
28 20 Additional headlights
29 15 Sound signal
30 10 ECM, relay coil in ECM main relay
2)
31 15 Transmission control module
32 15 Electromagnetic clutch A / C (excluding 5-cylinder diesel and 4-cylinder diesel B4207T7)
Coolant pump (5-cylinder diesel Start / Stop and B4207T7)
33 5 2008-2011: Washer relay
2012-2017: Relay coil in relay for A / C magnetic clutch (except for 5cyl. Diesels); relay coil in the coolant pump relay (1.6 petrol, 5-cylinder diesel Start / Stop); relay coils in the electrical cabinet in the engine compartment cooling zone (Start / Stop)
34 30 2008-2016: Starter relay
2017: Spare
35 20 Ignition coils (5-, 6-cyl. Gasoline); condenser (6-cyl.), engine control module (4-cyl. 2.0 l)
10 Ignition coils (4-cylinder petrol), glow plug control module (5-cylinder diesel)
36 10 2008-2013: Engine control module (petrol except 4-cyl. 2.0 l)
15 2008-2013: Engine Control Module (Diesel)
20 2014-2017: Engine Control Module (4-cyl.)
37 ten 2008-2013: Air mass meter (4-cyl.), Thermostat (4-cyl., Petrol), evaporator valve (4-cyl., Petrol), coolant pump for EGR (4-cyl., Diesel)
15 Air mass meter (5-cyl. Diesel, 6-cyl.); control valves (5-cylinder diesel); injectors (5-, 6-cyl. gasoline); engine control module (5-, 6-cyl. petrol)
38 15 Valves, oil pump (4-cyl., Petrol.), Lambda probe, middle (4-cyl., Petrol.), Lambda probe, rear (4-cyl., Diesel.)
10 Magnetic clutch A / C (5-, 6-cyl.), Valves (5-, 6-cyl.), Engine control module (6-cyl.), Air mass meter (5-cyl., Petrol), oil level sensor
39 15 EVAP valve, lambda probes, injection systems, radiator louver control module
10 Lambda probes, radiator blind control module
40 20 Vacuum pump, crankcase ventilation (5-cylinder turbo, 2.0 GTDI)
2008-2009: Diesel filter heater
15 2008-2009: Diesel Filter Heater, Crankcase Ventilation Heater (Diesel)
2014-2017: Ignition coils
10 2010-2013: Crankcase ventilation heater (5-cyl., Petrol)
20 2010-2013: Diesel filter heater, crankcase ventilation heater (5-cylinder diesel)
41 5 2008-2010: Spare
2011-2012: Crankcase ventilation heater (diesel)
2013-2017: Radiator shutter control module (5-cylinder petrol)
10 2012-2017: Crankcase ventilation heater (5-cylinder diesel), automatic transmission oil pump (5-cylinder diesel Start / Stop from 2013)
15 2014-2017: Electromagnetic clutch A / C (4-cyl. 2.0 lv); glow plug control module (4-cyl. 2.0 l diesel); oil pump (4-cyl. 2.0 l diesel)
42 70 Glow plugs (diesel)
50 2014-2017: Coolant pump (4-cyl. 2.0L petrol)
43 60 2011-2017: Cooling fan (4- and 5-cyl. Petrol)
80 2011-2017: Cooling fan (6-cyl. Petrol), (4-cyl. 2.0 l and 5-cyl. Diesel)
44 80 2008-2010: Cooling fan
2011-2017: Electro-hydraulic servo control (1.6D)
100 2011-2017: Servo amplifier
1) Until 2010
2) 4-cylinder engines from 2016


The Volvo XC60 models equipped with the Start-Stop system have another fuse box in the engine compartment since 2011.

Diagram
No. A Appointment
1 100 Additional electric heater
2 50 Primary fuse for the central electronic module (CEM) with fuse box B under the glove compartment
3 60 Primary fuse for the electrical distribution box in the passenger compartment with fuse box A under the glove compartment
4 60 Primary fuse for the electrical distribution box in the passenger compartment with fuse box A under the glove compartment
5 60 Primary fuse for the load compartment fuse box
6 40 Interior fan
7 - Empty
8 - Empty
9 30 Starter relay
10 50 Internal diode
11 70 Auxiliary battery
12 15 Central Electronic Module (CEM) (booster battery reference voltage)
5 2016-2017: Central Electronic Module (CEM) (booster battery reference voltage)
A1 175 Power fuse link in the power distribution box in the engine compartment
A2 175 Central electronic module (CEM) power fuse-link with fuse box B under the glove compartment, power distribution box in the passenger compartment with fuse box A under the glove compartment, power distribution box in the trunk

In the trunk


Located behind the trim on the left side of the luggage compartment. 


For models up to 2010, it consists of three boards (Black, White, Blue).


Since 2010, there is one board (black).

Fuse diagram in the luggage compartment Volvo XC60
2008-2017: Board # 1 (black)
No. A Appointment
1 25 2008-2010: Driver's door control module
30 2011-2017: Electric parking brake left
2 25 2008-2010: Control panel, passenger door
30 2011-2017: Electric parking brake right
3 25 2008-2010: Control panel, rear left door
30 2011-2017: Heated rear window
4 25 2008-2010: Control panel, rear right door
15 2011-2017: Trailer socket 2
5 20 2008-2010: Spare
2011-2017: POT (automatic tailgate opening)
6 15 2008-2010: 12V socket in luggage compartment
2011-2017: Spare
7 30 2008-2010: Heated rear window
2011-2017: Spare
8 - Spare
9 15 2008-2010: Trailer socket 2
2011-2017: Spare
10 25 2008-2010: Power seat, driver's side
2011-2017: Spare
11 40 Trailer socket 1
12 30 2008-2010: ROT (automatic tailgate opening)
2011-2017: Spare
2008-2010: Board # 2 (white)
No. A Description
1 5 Parking assistance, parking assistance camera
2 15 Four-C control module
3 15 Seat heating, front driver's side
4 15 Seat heating, front passenger side
5 15 Seat heating, right rear
6 10 AWD control module
7 15 Seat heating, left rear
8 - Spare
9 25 Power seat, passenger side
10 20 Keyless drive system
11 30 Electric parking brake, left
12 30 Electric parking brake, right
2008-2010: Board # 3 (blue)
No. A Decryption
1 10 RTI display
2 - Spare
3 25 Bass speakers
4 5 DAB radio
5 25 Audio amplifiers
6 15 Audio system
7 5 Phone, Bluetooth
8 - Spare
9 - Spare
10 - Spare
11 - Spare
12 - Spare
Related materials
Add new comment