Fuses and relays Volvo XC90 (C; 2002 - 2014)

The first generation of the luxury crossover Volvo XC90 was presented in 2002. Together with the S60, V70 and S80 models, it is built on the P2 platform. For its time, it became the largest among the crossovers produced by the company. In this material, we will analyze in detail the fuse circuits of the 1st generation Volvo XC90 (body C) 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014 release.


Here you will find the locations and photos of the fuse blocks. Separately, we note the elements responsible for the cigarette lighter and fuel pump.

Blocks arrangement


The fuse boxes are located in four locations.
1. in the engine compartment.
2. in the passenger compartment behind the soundproofing on the driver's side.
3. in the passenger compartment at the end of the dashboard on the driver's side.
4. in the luggage compartment.  

In the engine compartment


To access the fuses, press the plastic tabs on the short sides of the unit and pull the cover up.

 
Photo - example (type 1).

Diagram (type 1)
No. Description A
1 ABS 30
2 ABS 30
3 High pressure headlamp washers 35
4 Parking heater (option) 25
5 Additional headlights (option) 20
6 Starter relay 35
7 Windshield wipers 25
8 Fuel pump fuse Volvo XC90 15
9 Transmission Control Module (TCM), (V8, Diesel, 6-cylinder petrol) 15
10 Ignition coils (petrol), engine control module (ECM), injection valves, (diesel) 20
11 Fuel pedal position sensor (AWP), AC compressor, fan, electronic unit 10
12 Engine control module (ECM) (petrol), injectors, (petrol), air flow meter (petrol); air mass meter (diesel) 15, 5
13 Throttle control module (V8), V1S (6-cylinder petrol); throttle control module, solenoid valve, SWIRL (air mixture valve), fuel pressure regulator (diesel) 10, 15
14 Lambda probe (gasoline); lambda probe (diesel) 20, 10
15 Crankcase ventilation heater, solenoid valves, leak diagnostics (5-cyl. Gasoline); Crankcase ventilation heater (V8, 6-cyl. Petrol), AC clutch (V8, 6-cyl. Petrol), solenoid valves, leak diagnosis (V8, 6-cyl. Petrol), ECM, (V8, 6-cyl. Petrol) ), air mass meter (V8), glow plugs (diesel) 10, 15
16 Low beam headlights, left 20
17 Dipped headlights, right 20
18 Reserve socket  
19 Engine control unit (ECM), power, engine relay 5
20 parking lights 15
21 Reserve socket  
Description of fuse box in the engine compartment (type 2)

Block example.

Diagram.
No. Decoding A
F1 Additional heater control unit 25
F2 Optional equipment 20
F3 Engine management - Bi-fuel, vacuum pump (2002) 15
F4 Heated oxygen sensors, engine management (Diesel) 20
F5 Engine management system (petrol) 15
F6 15
F7 -  
F8 Accelerator Pedal Position Sensor, A / C Compressor Clutch Relay, Fuse / Relay Box Cooling Fan 10
F9 Sound signal 15
F10 Rear window washer pump motor 10
F11 Engine Management, Glow Plugs, HVAC System, Crankcase Ventilation Heater (Diesel) 20
F12 Stop lights 5
F13 Windshield wiper 25
F14 Anti lock brake system ABS / ESP (DST C) 30
F15 Headlight washer / washer system 25
F16 Windshield washer pump motor 15
F17 Right headlight - low beam (xenon) 10
F18 Left headlight - low beam xenon) 10
F19 Anti-lock braking system ABS / ESP (DSTС) 30
F20 Left headlight-high beam 15
F21 Right headlight - high beam 15
F22 Starter 25
F23 Engine control relay, electronic engine control unit (ECM) 5
F24 -  
The purpose of the relay in the block
1 -
2 Engine management system
3 Glow plugs
4 Starter
5 Intermittent operation of the windshield wiper
6 Headlight washer / washer
7 -
8 A / C Compressor Electromagnetic Clutch
9 Beep
10 Windshield washer pump
11 Windshield wiper motor
12 Rear window washer pump motor
Power fuses on the back of the unit
No. Decoding A
F1 Glow plugs 60
F2 Passenger compartment block #1: fuses (F5-7), (F25-27), (F32-33) 60
F3 Passenger compartment block #1: fuses (F3-4), (F8-11), (F16-19), (F34-38) 60
F4 Passenger compartment block #1: fuses (F1), (F12-15), (F20-24) 60
F5 Empty  
F6 Empty  
F7 Empty  
F8 Cooling fan motor 60

In the passenger compartment

From the end of the dashboard


Fuse box located behind the soundproofing panel on the driver's side. A sticker indicating the fuse position and the number of amperes is located under the end block cover.

Diagram
No. Description A
1 Air conditioner fan 30
2 Audio system (amplifiers) 30
3 Electric driver's seat 25
4 Electric passenger seat 25
5 Left control unit, front door 25
6 Right control unit, front door 25
7 Reserve socket  
8 Radio, CD player, RSE system 15
9 RTI display, MMM RTI module 10
10 OBDII, Light Switch (LSM), Steering Angle Sensor (SAS), Steering Wheel Control Module (SWM) 5
11 Ignition switch, SRS, ECM (V8, 6-cylinder petrol) Passenger side SRS deactivation (PACOS), Electronic start lock (IMMO), TCM transmission control module (V8, diesel, 6-cylinder petrol) 7.5
12 General lighting, ceiling (RCM), upper electronic control module (UEM) 10
13 Sunroof 15
14 Telephone 5
15-38 Reserve sockets  

Behind the bottom panel


To access, unscrew the two fixing screws and remove the cladding panel.


Access example.

Diagram
No. Description A
1 Heated seat, right side 15
2 Seat heating, left side 15
3 Sound signal 15
4 Reserve socket  
5 Infotainment system 10
6 Reserve socket  
7 Reserve socket  
8 Alarm siren 5
9 Brake signal contacts, power supply 5
10 Combination Instrument (DIM), Climate Control (CCM), Parking Heater, Power Driver Seat 10
11
  • 12V socket, front seat, rear seat and refrigerator
  • Volvo XC90 cigarette lighter fuse
15
12 Reserve socket  
13 Reserve socket  
14 Reserve socket  
15 ABS, STC / DSTC 5
16 Electronic servo control (ECPS), active bi-xenon (HCM), headlight beam height adjustment 10
17 Fog lamp, front left 7.5
18 Fog lamp, front right 7.5
19 Reserve socket  
20 Coolant pump (V8) 5
21 Communication control unit (TOM), reverse gear lock (M66) 10
22 High beam headlights, left 10
23 High beam headlights, right 10
24 Reserve socket  
25 Reserve socket  
26 Reserve socket  
27 Reserve socket  
28 Electric passenger seat 5
29 Fuel pump 7.5
30 BUS 5
31 Reserve socket  
32 Reserve socket  
33 Vacuum pump 20
34 Washer fluid pump 15
35 Reserve socket  
36 Reserve socket  
Cabin Relay Modules
The board is located behind the bottom panel above the main unit.
No. Relay module
1 -
2 Auxiliary ignition circuits
3 Main ignition circuits
4 -
5 -
6 Power Window Regulator - Close Left Rear Door
7 power window regulator - opening, left rear door
8 turning off the electric motors of the rear power windows, blocking the doors from accidental opening - rear doors
9 high beam headlights
10 Parking lamps
11 Daytime lighting system
12 low beam headlights
13 Power Window Relay - Close, RH
14 Power Window Relay - Opening, RH Door
15 Relay 2 auxiliary ignition circuits
16 Transmission control system
17 -
18 -
19 -
20 -
21 Telematics
22 -
23 -
24 -
25 -
26 -
27 Fog lights
28 Fuel pump relay Volvo XC90
29 -
30 Fuel leakage control relay
31 Jumper - left direction indicators
32 Jumper - right direction indicators
33 -
34 Jumper - low beam headlights
35 -

In the trunk


Located behind the trim on the left side of the luggage compartment. For Executive modifications, an auxiliary board can be attached next to it.

Description of the luggage compartment fuse box (option 1)

Photo is an example.

Diagram.
No. Description A
1 Reversing light 10
2 Parking lights, fog lights, luggage compartment lights, license plate lights, brake lights 20
3 Accessories (AEM) 15
4 Reserve socket  
5 Electronic equipment REM 10
6 Rear Seat Entertainment RSE (Accessory) 7.5
7 Wiring (30 power) 15
8 Electrical socket in the luggage compartment 15
9 Rear door, right: power window, power window lock 20
10 Tailgate, LH: Power Window, Power Window Lock 20
11 Reserve socket  
12 Reserve socket  
13 Diesel filter heater 15
14 Subwoofer, rear air conditioning (A / C) 15
15 Reserve socket  
16 Reserve socket  
17 Additional audio equipment 5
18 Reserve socket  
19 Rear cleaner 15
20 Wiring (15 power) 20
21 Reserve socket  
22 Reserve socket  
23 AWD 7.5
24 Reserve socket  
25 Reserve socket  
26 Parking assistance 5
27 Main fuse: wiring to trailer, park assist, AWD 30
28 Central locking (PCL) 15
29 Trailer lighting on the left: side lights, direction indicators 25
30 Trailer lighting, right: brake light, rear fog lights, direction indicators 25
31 Main fuse 40
32 Reserve socket  
33 Reserve socket  
34 Reserve socket  
35 Reserve socket  
36 Reserve socket  
37 Heated rear window 20
38 Heated rear window 20
Trunk fuse box (Type 2)

General form.

Diagram.
No. Description A
F1 Multifunction control unit 2, interior lighting-luggage compartment lighting 10
F2 Rear fog lights 10
F3 Stop lights 15
F4 Reversing lights 10
F5 Heated rear window, trailer power relay 5
F6 Rear door opening drive 10
F7 Accessory Power Connector - Luggage Compartment 15
F8 Central locking - locking rear side doors / rear door hatch / fuel filler cap 15
F9 Trailer electrical connector 20
F10 Antenna Signal Booster 5
F11 Optional equipment 15
F12 Rear window wiper motor 15
F13 Audio system, air conditioning / heating system - rear 15
F14 Stop lights 7.5
F15 Trailer electrical connector 20
F16 Not used (2002)  
F17 Fuel filter heater (Diesel), differential lock control unit 7.5
F18 Fuel filter heater (diesel) 15
1 -  
2 -  
3 -  
4 Relay for intermittent operation of the rear window wiper  
5 Bi-fuel relay  
6 A / C ECU Relay - Rear A / C  
7 Rear door drive relay  
8 Not used (2002)  
9 Lock actuator relay fuel filler neck - open  
10 -  
11 Rear right door central locking relay - unlocking  
12 -  
13 -  
14 Rear wiper motor relay  
15 -  
16 -  
17 -  
18 -  
19 Jumper - brake lights  
20 Jumper - rear parking lights  
21 Jumper - rear parking lights  
22 Jumper-connector for power supply of additional equipment in the luggage compartment  
23 Jumper - fog lights  
24 -  
25 Rear Fog Lamp Relay - Trailer  
26 Rear fog lamp relay  
27 Brake light relay  
28 Reversing light relay  
29 Central locking relay, rear - double locking  
30 Left rear door central locking relay - unlocking  
31 Fuel lock drive relay - close, central locking relay - rear doors - close (2002)  
32 Fuel filter heater relay (diesel)  
33 -  
34 Heated rear window relay  
35 Audio system  
36 Relay for power supply of the trailer electrical equipment connector  
Accessory board (Executive version)
No. Appointment A
1 Relay for heating the rear seat and massage of the front seats 5
2 Heated driver's rear seat 15
3 Heated rear seat, passenger side 15
4 Front seat ventilation / massage 10
5 Empty -
6 Empty -
Power fuses near the battery
No. Description A
1 Luggage Fuse Box Chains (F15-18) 40
2 Luggage Fuse Box Chains (F12-13) 40
3 Heated rear window 40
4 Empty -
5 Luggage Fuse Box Chains (F6-11) 40
6 Empty -
7 Luggage Fuse Box Chains (F1-5) 40
General layout of electronic modules in Volvo XC90
1 Bodywork control unit - luggage compartment right
2 Air conditioning ECU - behind the air conditioning control panel
3 Air conditioner / heater fan control unit - next to the fan motor
4 Antenna unit, telephone
5 Antenna Signal Amplifier - Ceiling Panel
6 Impact sensor, left
7 Shock sensor, right
8 Safety curtain igniter, lion
9 Safety shutter igniter. Right.
10 Side Impact Sensor Assembly - Driver Side B-Pillar
11 Side impact sensor, rear left - behind the support on the rear seat cushion
12 Side Impact Sensor Assembly - Passenger Side B-Pillar
13 Side impact sensor, rear right - behind the support on the rear seat cushion
14 Vehicle tilt sensor (anti-theft system)
15 Anti-theft alarm horn behind the front right wheel arch trim
16 Volume change sensor (anti-theft system) - ceiling panel
17 Anti-theft alarm sensor - in multifunction control unit 3
18 Audio system output amplifier
19 Additional heater control module, if installed
20 Battery - under floor luggage compartments
21 Cruise control module built into the ECM.
22 Diagnostic connector (DLC)
23 Differential Lock Control Module - Rear Differential
24 Passenger Door Electrical Control Module - In Door - Functions: Central locking, door open or tightly closed indicators, door mirrors power / heater, power windows, door mirror lights, outside temperature
25 Driver's door electrical control module - in the door - functions: Central locking, door open or loosely closed indicators, power / heated door mirrors, power windows, door mirror lights, outside temperature
26 Cooling Fan Motor Control Module
27 Fuse box, engine compartment 1
28 Fuse Box 2 - Under Engine Compartment Box 1
29 Fuse box in the end of the dashboard
30 Fuse box at the bottom of the instrument panel
31 Fuse / relay box, luggage compartment 1
32 Power fuse box 2 - next to the battery
33 Heater ECU - behind the heater controls
34 Horn - behind the front bumper
35 Immobilizer - in the electronic engine control unit
36 Immobilizer ring antenna - near the ignition switch
37 Turn signal / alarm relay - in multifunction control box 1
38 Instrument Cluster Control Module - Instrument Cluster
39 Lighting control module - behind the headlight switch
40 Multifunction control unit 1 - connected by dashboard fuse / relay box 2 - functions:
  Anti-theft system, power window central locking, windshield wiper / washer, headlight washer / washer, power steering, immobilizer, headlights, turn / alarm indicators, horn, front / rear parking lamps, starter, heated seats, headlight range control, fuel pump, glove box illumination lamp
41 Multifunction control unit 2 - connected by fuse / relay box, luggage compartment 1 - functions: Anti-theft system, central locking, taillights, fuel level, interior lamps, rear window wiper / washer, heated rear window, accessory power connectors - rear, parking system, under the heater of fuel and a clear filter -Diesel
42 Multifunctional control unit 3- functions: Central locking, anti-theft system, sunroof, rain sensor, interior lamps, seat belt reminder
43 Navigation control module - under the left seat
44 Ambient air temperature sensor - in the mirror of the right door
45 Parking system control module
46 Power steering relay
47 Rain sensor (if installed)
48 Relay for door locking system against accidental opening, left. - at the door
49 Relay for door locking system against accidental opening, right, - in the door
50 Driver's seat power control module - under the seat
51 Seat occupant sensor - in the seat cushion
52 SRS ECU
53 Steering Wheel Position Sensor Module - Connected to under-dash fuse / relay box 2
54 Steering wheel control unit - behind the steering wheel - functions: Audio system, cruise control, horn, direction indicators, windscreen wiper / washer, rear window wiper / washer, dipped / main beam headlights
55 Sunlight sensor
56 Sunroof control module - in multifunction control unit 3
57 Transmission ECU
59 Telematics module - functions: Audio system, telephone
60 Telephone control module, "hands-free"
61 Phone interface control module - behind the air conditioner control panel
Related materials
Comments
jean-jacques cadieux

cx 90 2007 is not there

Add new comment