The Mazda 5 compact van is produced for the European market in Japan and is the left-hand drive counterpart of the Premacy. The second generation, released in 2004, became a production version of the MX Flexa concept car. In 2007, it was restyled. In this article, we will take a detailed look at the fuse box diagrams for the Mazda 5 (second generation; codename CR) 2004, 2005, 2006, 2007, 2008, 2009, 2010 years of manufacture.
Here you will find the locations and photos of distribution boxes. The fuses responsible for the “Cigarette lighter” and “Fuel Pump” are highlighted in bold.
In the engine compartment
The fuse box is located on the left side. Remove the protective cover to access it.
Access example.
| Diagram | ||
|---|---|---|
|
||
| No. | Description | Amps |
| R1 | Engine control relay | |
| R2 | Dipped beam relay | |
| R3 | High beam relay | |
| R4 | Tail light relay | |
| R5 | A/C/Heater Fan Motor Relay | |
| R6 | Empty | |
| R7 | Rear window defroster relay | |
| R8 | Fuel pump relay (fuel module) | |
| R9 | A/C compressor magnetic clutch relay | |
| R10 | Rear fog lamp relay | |
| R11 | Not used | |
| R12 | Starter relay | |
| R13 | Cooling fan electric motor relay | |
| R14 | Glow plug relay | |
| R15 | Fog light relay | |
| R16 | Not used | |
| R17 | Headlight wiper/washer relay | |
| R18 | Horn relay | |
| 1 | Cooling fan motor control unit | 30 |
| 2 | 30 | |
| 3 | Electric windows | 40 |
| 4 | Egnition lock | 30 |
| 5 | Electronic control unit ABS/ESP (ABS brakes) | 20 |
| 6 | 30 | |
| 7 | Egnition lock | 20 |
| 8 | HEATER DEICER TCM - Heater (defroster) | 20 |
| 9 | A/C/Heater Fan Motor | 40 |
| 10 | Glow plugs (Diesel) | 40 |
| 11 | Fuse/relay box in the engine compartment (fuses 31-33) | 40 |
| 12 | IG KEY2 - For protecting various circuits | 40 |
| 13 | CLOSER P.SLIDE LH — Left door closer | 20 |
| 14 | CLOSER P.SLIDE RH — Right door closer | 20 |
| 15 | Power steering | 80 |
| 16 | Fog lights | 15 |
| 17 | Сentral locking | 20 |
| 18 | Headlight washer/cleaner system | 20 |
| 19 | Air conditioner compressor solenoid clutch | 10 |
| 20 | Heated rear window, heated mirrors | 25 |
| 21 | Engine control | 10 |
| 22 | Horn, brake lights | 10 |
| 23 | Fuel pump fuse | 20 |
| 24 | Turn signals/danger warning signals | 10 |
| 25 | Interior lamps | 15 |
| 26 | Not used | - |
| 27 | Magnetic coupling | 10 |
| 28 | Glow plug indicator | 7.5 |
| 29 | Right high beam headlight | 10 |
| 30 | Left high beam headlight | 10 |
| 31 | Horn | 15 |
| 32 | Sunroof | 20 |
| 33 | Anti-theft system | 7.5 |
| 34 | Right dipped beam headlight | 15 |
| 35 | Left dipped beam headlight | 15 |
| 36 | Heated oxygen sensor | 15 |
| 37 | Exhaust gas recirculation (EGR) system | 15 |
| 38 | Engine control | 15 |
| 39 | Dashboard illumination | 10 |
| 40 | Fog lights, tail lights | 10 |
The main power fuse is located on the positive terminal of the battery.
In the passenger compartment
Located at the end of the instrument panel on the passenger side.
Access example.
| Diagram | ||
|---|---|---|
|
||
| № | Description | Amps |
| 1 | M.DEF - Heated mirrors (in some packages) | 7.5 |
| 2 | STARTER | 10 |
| 3 | Engine control unit - ENG3 | 20 |
| 4 | P.OUTLET - Accessory connector | 15 |
| 5 | SHIFT / L - Transmission switch | 5 |
| 6 | CIGAR - Mazda 5 cigarette lighter fuse | 15 |
| 7 | MIRROR - Mirror, electric adjustment, audio system (in some packages) | 7.5 |
| 8 | Air Conditioning - A / C | 10 |
| 9 | F.WIP - Wipers and windshield washer | 25 |
| 10 | R.WIP - Rear window wiper and washer | 15 |
| 11 | Main relay (in some packages), PCM (in some packages) | 5 |
| 12 | METER - Instrument panel. Automatic headlight range control (in some packages) | 10 |
| 13 | SAS - Additional restraint systems, SRS | 10 |
| 14 | Seat heating (in some packages) | - |
| 15 | 5F ABS, DSC - ABS | - |
| 16 | EHPAS - Electrohydraulic power steering system | 5 |
| 17 | ENG2 - Engine management | 15 |
| 18 | P / W - Power windows | - |
| 19 | P / W - Power windows | - |
General arrangement
Schematic diagram of the vehicle's electrical system.
|
|
| No. | Component |
| 1 | Air conditioning control module (in the heater control panel) |
| 2 | Some light sensors (air conditioning system) |
| 3 | Heater/air conditioner fan motor resistor (automatic temperature control) - passenger legroom |
| 4 | Heater/air conditioner fan motor resistor (manual temperature control) - driver's legroom |
| 5 | Antenna module, front, (keyless entry system) |
| 6 | Antenna module, interior (keyless entry system) |
| 7 | Antenna module, rear (keyless entry system) |
| 8 | Antenna module, rear door (keyless entry system) |
| 9 | Impact sensor (SRS), front |
| 10 | Volume change sensor (anti-theft system), front - with sunroof |
| 11 | Volume change sensor (anti-theft system), front - without sunroof |
| 12 | Volume change sensor (anti-theft system), rear |
| 13 | Anti-theft alarm system buzzer - left side of luggage compartment |
| 14 | Interference suppressor (audio system) - left side of luggage compartment |
| 15 | Battery |
| 16 | Central locking system signal control unit |
| 17 | Diagnostic connector (DLC) |
| 18 | Left tailgate electrical control module - left side of luggage compartment |
| 19 | Right rear door electrical control module - right side of luggage compartment |
| 20 | Power window control module (in the switch on the driver's door) |
| 21 | Cooling fan motor control module |
| 22 | Fuse module / relay, engine compartment |
| 23 | Fuse module in the passenger compartment |
| 24 | Xenon headlight control module, left-hand side |
| 25 | Xenon headlight control module, right-hand side |
| 26 | Headlight washer pump |
| 27 | Horn (upper) |
| 28 | Horn (lower) |
| 29 | Immobilizer control module - in instrument cluster |
| 30 | Immobilizer ring antenna - near the ignition switch |
| 31 | Cabin air temperature sensor |
| 32 | Turn signal relay - in the multifunction control unit |
| 33 | Instrument cluster control module (in the instrument panel) |
| 34 | Keyless entry system control module |
| 35 | light sensor |
| 36 | Multifunction control unit-functions: Anti-theft system, central locking, exterior lamps,turn signal/emergency lights, fog lights, rear window wiper/washer, windshield wiper/washer |
| 37 | Navigation Antenna - Behind the Instrument Panel |
| 38 | Navigation control module |
| 39 | Ambient air temperature sensor |
| 40 | Power steering control module - in the power steering pump |
| 41 | Rear window washer pump motor |
| 42 | Additional fuse (gasoline - 250A /Diesel - 450A) - power distribution (charging and starting systems) |
| 43 | Side impact sensor, front left - lower B-pillar |
| 44 | Side SRS sensor, left rear |
| 45 | Side impact sensor, front right - lower B-pillar |
| 46 | Side SRS sensor, right rear |
| 47 | Steering wheel position sensor (power steering system) - under the steering wheel |
| 48 | Power sunroof control module |
| 49 | Electronic control unit SRS |
| 50 | Body height sensor (rear)- on the suspension system |
| 51 | Electronic transmission control unit (automatic transmission) - in the electronic engine control unit (diesel) |
| 52 | Electronic transmission control unit (automatic transmission) - in the electronic engine control unit (gasoline) |
| 53 | Vehicle speed sensor - ABS electronic control unit |
| 54 | Voice synthesizer (navigation system) |
| 55 | Buzzer (keyless entry system) - behind the wheel arch cover of the front left wheel |
| 56 | Windshield washer reservoir low level sensor |
| 57 | Windshield washer pump electric motor |
| 58 | Rain sensor (windshield wiper) |
Very detailed
Thanks