The Opel/Vauxhall Corsa D debuted in July 2006. Built on the SCCS platform shared with the Fiat Grande Punto, the Corsa D is 31 mm shorter than its counterpart. A commercial panel van variant was also offered under the "Corsavan" nameplate. The model received a facelift in November 2010. This article details the fuse box diagrams, relay layouts, and pinouts for the Opel / Vauxhall Corsa D (fourth generation; S07 chassis; Gamma II platform) produced from 2006 through 2014.
Below you will find fuse box locations, component diagrams, and layout photographs. Fuses for high-demand circuits such as the "Cigarette Lighter / Power Outlet" and "Fuel Pump" are highlighted in bold.
Passenger Compartment Fuse Box
The cabin fuse box is located on the driver’s side, positioned behind the headlight switch panel.
To access the fuses, pull down firmly on the top edge of the panel to unlatch it.
Overview of the Corsa D passenger compartment fuse panel.
| Diagram | ||
|---|---|---|
|
||
| No. | Circuit Protected | Rating (A) |
| 1 | Not used | — |
| 2 | Instrument cluster, multi-function display | 10 |
| 3 | Infotainment system / Head unit | 20 |
| 4 | Ignition switch | 7.5 |
| 5 | Windshield wipers | 20 |
| 6 | Tailgate central locking mechanism | 15 |
| 7 | Side door central locking mechanism | 20 |
| 8 | Not used | — |
| 9 | Interior lighting | 10 |
| 10 | Electric Power Steering (EPS) control module | 7.5 |
| 11 | Light switch module, brake light switch, clutch pedal switch | 7.5 |
| 12 | ABS control module, brake lights | 7.5 |
| 13 | Heated steering wheel | 30 |
| 14 | FlexFix rear carrier system, Park Assist, rain sensor, electrochromic rear-view mirror, center console switch cluster | 7.5 |
Engine Compartment Fuse Box
Located under the hood adjacent to the battery, the engine compartment housing contains the main fuse box (1) and the battery pre-fuse / power distribution module (2), as indicated above.
Main Fuse Box
Depending on the model year and trim configuration, two primary fuse box variants were fitted.
Type 1
Models produced from 2008 onwards.
General view.
| Diagram | ||
|---|---|---|
|
||
| No. | Relay Assignment | |
| K1 | Horn relay | — |
| K2 | Ignition relay (Terminal 15) | — |
| K3 | Fuel filter heater relay** | — |
| K4 | High beam headlamp relay | — |
| K5 | A/C compressor clutch relay | — |
| K6 | Front fog lamp relay | — |
| K7 | Radiator cooling fan relay | — |
| K8 | Engine Control Module (ECM) relay | — |
| K9 | Starter motor relay | — |
| K10 | Fuel pump relay | — |
| K11 | Ignition relay (Terminal 15) | — |
| K12 | Heated rear window relay | — |
| K13 | Radiator cooling fan relays | — |
| K14 | — | |
| No. | Circuit Protected | Rating (A) |
| 1 | Starter motor solenoid | 30 |
| 2 | Air conditioning system | 7.5 |
| 3 | Diesel fuel pre-heater system** | 30 15* |
| 4 | Horn | 15 |
| 5 | Easytronic automated manual transmission / Automatic transmission | 15 |
| 6 | Engine Control Module (ECM) | 7.5 |
| 7 | Front fog lamps | 15 |
| 8 | Engine cooling fan module | 30 40* |
| 9 | Engine cooling fan module | 30 40 60* |
| 10 | Easytronic control module | 30, 60* |
| 11 | Glow plug control module, ignition system | 7.5 15* |
| 12 | Light switch module, headlamp leveling, Adaptive Forward Lighting (AFL) | 5 |
| 13 | Climate control system / HVAC control panel | 7.5 |
| 14 | Easytronic control module / Transmission Control Module (TCM) | 5 |
| 15 | Right high beam, right adaptive main beam headlight | 10 |
| 16 | Left high beam, left adaptive main beam headlight | 10 |
| 17 | Main power distribution supply | 10 |
| 18 | Engine Control Module (ECM) power supply | 7.5 |
| 19 | Supplemental Restraint System (SRS / Airbag module) | 10 |
| 20 | Main power distribution supply | 10 |
| 21 | Main power distribution supply | 15 20* |
| 22 | Body Control Module (BCM) | 70 |
| 23 | Tire repair kit compressor | 20 |
| 24 | Fuel pump fuse | 15 |
| 25 | ABS / ESP control module | 30 |
| 26 | Heated rear window | 30 |
| 27 | ABS system | 30 |
| 28 | Blower motor (HVAC / Climate control) | 30 |
| 29 | Cigarette lighter / 12 V power outlet fuse | 20 |
| 30 | Air conditioning / Climate control module | 7.5 |
| 31 | Left front power window switch module | 20 |
| 32 | Right front power window switch module | 20 |
| 33 | Heated exterior mirrors | 7.5 |
| 34 | Not used | |
| 35 | Not used | — |
Type 2
Models produced up to 2008.
General view.
| Diagram | ||
|---|---|---|
|
||
| No. | Circuit Protected | Rating (A) |
| R1 | A/C compressor clutch relay | |
| R2 | High beam relay | |
| R3 | Not used | |
| R4 | Horn relay | |
| R5 | Engine Control Module (ECM) relay | |
| R6 | Ignition relay (Terminal 15) | |
| R7 | Starter motor relay | |
| R8 | Not used | |
| R9 | Not used | |
| R10 | Fuel pump relay | |
| R11 | Front fog lamp relay | |
| R12 | Fuel filter heater relay | |
| R13 | Radiator cooling fan relays | |
| R14 | ||
| R15 | ||
| R16 | Ignition relay (Terminal 15) | |
| R17 | Heated rear window relay | |
| 1 | Not used | — |
| 2 | Headlamp leveling control module | 10 |
| 3 | Heater and air conditioning controls | 7.5 |
| 4 | Automatic / Manual transmission control module | 15 |
| 5 | Airbag control module (SRS) | 20 |
| 6 | Climate control module / A/C system | 7.5 |
| 7 | Power mirror controls | 10 |
| 8 | Ignition coils, Mass Air Flow (MAF) sensor, glow plug control unit, fuel-in-water sensor, fuel heater module | 15 |
| 9 | Engine Control Module (ECM) | 7.5 |
| 10 | Starter motor relay coil | 30 |
| 11 | Fuel pump relay supply fuse | 15 |
| 12 | Anti-lock Braking System (ABS) module | 30 |
| 13 | A/C compressor clutch | 10 |
| 14 | Right high beam headlamp | 10 |
| 15 | Left high beam headlamp | 10 |
| 16 | Not used | — |
| 17 | Fuel injectors | — |
| 18 | Horn relay circuit | 15 |
| 19 | Transmission Control Module (TCM) | 15 |
| 20 | Not used | — |
| 21 | Twinport flap actuator, heated oxygen sensors (HO2S), EGR valve, boost pressure control solenoid, evaporative emission (EVAP) purge valve | 15 |
| 22 | Engine Control Module (ECM) power supply | 15 |
| 23 | ECM relay coil, Engine Control Module | 7.5 |
| 24 | Compressor clutch control, Cigarette lighter / 12 V power outlet fuse | 30 |
| 25 | Power windows | 20 |
| 26 | Fuel filter heater relay circuit | 30 |
| 27 | Power windows | 20 |
| 28 | Front fog lamp relay circuit | 15 |
| 29 | Engine Control Module, fuel injectors (cylinders 1–4) | 20 |
| 30 | Not used | — |
| 31 | Anti-lock Braking System (ABS) pump motor | 40 |
| 32 | Engine cooling fan module | 50 |
| 33 | Engine cooling fan module | 60 |
| 34 | HVAC blower motor / Climate control module | 40 |
| 35 | Manual transmission controls | 30 |
| 36 | Heated rear window element | 30 |
| 37 | A/C compressor relay, instrument cluster module | 60 |
Battery Pre-Fuse Box
Mounted directly on the battery positive terminal.
| Diagram | ||
|---|---|---|
|
||
| No. | Circuit Protected | Rating (A) |
| 1 | Diesel pre-heating system / Glow plug power supply | 80 |
| 2 | Electric Power Steering (EPS) system | 80 |
| 3 | Auxiliary heater / Auxiliary cabin heating unit | 60 |
| 4 | Main power feed to load compartment electrical center | 50 |
| 5 | Auxiliary heater / Auxiliary cabin heating unit | 40 |
Auxiliary Fuse & Relay Block
Located on the right side of the engine compartment. Installation depends on vehicle equipment and option packages.
Component Legend:
R16 — Radiator fan relay;
F1 — Air conditioning fuse;
F2 / F3 — Auxiliary heater fuses.
Luggage Compartment Fuse Box
Located on the left side of the trunk paneling.
To access the fuse box, insert a finger or lever tool into the cutout notch, unlatch the trim access cover, and pull it away.
| Diagram | ||
|---|---|---|
|
||
| No. | Circuit Protected | Rating (A) |
| 1 | Adaptive Forward Lighting (AFL) control module | 15 |
| 2 | Not used | — |
| 3 | Left heated front seat | 15 |
| 4 | Right heated front seat | 15 |
| 5 | Not used | — |
| 6 | Not used | — |
| 7 | Not used | — |
| 8 | FlexFix carrier system module, trailer hitch wiring module | 20 |
| 9 | Not used | — |
| 10 | Not used | — |
| 11 | Not used | — |
| 12 | Not used | — |
| 13 | Not used | — |
| 14 | Not used | — |
| 15 | FlexFix carrier system module, trailer hitch wiring module | 20 |
| 16 | Not used | — |
| 17 | Power sunroof / panoramic roof module | 20 |
| K1 | Ignition relay (Terminal 15a) | — |
Thanks for your help