Daily is a family of light-duty trucks and passenger buses of small capacity, produced by the Italian company Iveco S.p.A. One of the oldest models of the concern, the first generation appeared in 1978. In this article we will understand in detail fuse box diagrams Iveco Daily (second generation; restyling) 2006, 2007, 2008, 2009, 2010, 2011 years of manufacture.
Here you will find the locations and photos of the mounting blocks. Also, we will separately mark the fuses responsible for the cigarette lighter and the fuel pump.
| General arrangement of electronic units | |
|---|---|
|
|
| A | Instrument cluster |
| B | Key switch |
| C | Switch block on the steering column |
| D | Interconnection central unit ”CPL” |
| E | Body Computer |
| F | Battery |
| G | Positive (+30) distribution central unit ”CBA” |
| H | Alternator |
| I | Engine: interconnection central unit ”CVM”. |
In the engine compartment
Component locations: 1: "CBA" - distribution center block'; 2: "CVM" - inter-unit central unit
Fuse box #1 "CBA"
General view.
| Diagram | ||
|---|---|---|
|
||
| No. | Description | Amps |
| 1 | +30 for alternator starter | 500 A |
| 2 | to the CVM unit | 150 A |
| 3 | +30 for ”CPL” | 70 A |
| 4 | 70 A | |
| 5 | +30 for box OPT | 50 A |
| 6 | +30 for ”CPL” - OPT prearrangement | - |
Fuse box #2 "CVM"
General view.
| Diagram | ||
|---|---|---|
|
||
| No. | Description | Amps |
| T02 | Right and left high beam headlamps | 20 A |
| T03 | Horn (beep) | 20 A |
| T05 | Baruffaldi power supply | 20 A |
| T06 | Mirror and windshield heater | 20 A |
| T07 | Side position lights | 20 A |
| T08 | Heater or climate control system fans | 20 A |
| T09 | EDC16 (main relay) | 20 A |
| T10 | Fuel pump | 20 A |
| T14 | Left and right front fog lights | 20 A |
| T17 | Windscreen washer | 20 A |
| T19 | Fuel filter heater | 20 A |
| T20 | Diagnosis MODUS | 20 A |
| T25 | Windscreen wiper on/off | 10/20 A |
| T26 | Windscreen wiper 1st / 2nd speed | 10/20 A |
| 0 | Ignition glow plugs | 60 A |
| 1 | ABS or ESP | 40 A |
| 2 | 30 A | |
| 3 | ECU ESV1 (automatic gearbox) | 30 A |
| 4 | 30 A | |
| 5 | Start-up switch | 30 A |
| 6 | Mirror and windshield heating | 20 A |
| 7 | Side position lights | 20 A |
| 8 | Heater or climate control system fans | 30 A |
| 9 | Windscreen washer | 20 A |
| 10 | Horn (beep) | 7,5 A |
| 11 | EDC16 (secondary loads) | 10 A |
| 14 | Right hight beam headlight | 7,5 A |
| 15 | Left hight beam headlight | 7,5 A |
| 16 | EDC16, T02, T14, Additional heater | 5 A |
| 17 | EDC16 (primary loads) | 15 A |
| 18 | ECU ESV1 (automatic gearbox) | 10 A |
| 19 | Baruffaldi | 5 A |
| 20 | Fuel filter heater | 25 A |
| 21 | Iveco Daily fuel pump fuse | 15 A |
| 22 | EDC16 (primary loads) | 25 A |
| 23 | Additional heater | 10 A |
| 24 | ECU ESV1 (automatic gearbox), PTO | 15 A |
| 26 | Trailer socket | 10 A |
| 29 | Air spring suspensions | 40 A |
| 30 | Left and right front fog lights | 15 A |
| 54 | Air spring suspensions | 40 A |
Optional fuse box
Installed on some modifications.
| Diagram | ||
|---|---|---|
|
||
| No. | Amps | Description |
| Relays | ||
| T04 | 20 A | Turning lights |
| T16 | 10 A | Working lights |
| T15 | - | Empty |
| T22 | 20 A | Switching on the air conditioner compressor |
| T18 | 20 A | Baruffali cut-out |
| T24 | 20 A | Engaging the PTO |
| T23 | 20 A | Air conditioning compressor (A/C) |
| T21 | 20 A | Compressor ON signal fro EDC 16 |
| Fuses | ||
| F55 | 10 A | Turning lights |
| F25 | 10 A | Trailer connector |
| F28 | 15 A | APU power supply |
| F27 | 10 A | Working lights |
In the passenger compartment
Located behind the plastic cover on the left side of the dashboard.
General view of the Iveco Daily cabin fuse box.
| Diagram | ||
|---|---|---|
|
||
| No. | Description | Amps |
| 12 | Right dipped headlight | 7,5 A |
| 13 | Left dipped beam headlamp - headlamp position rectifier | 7,5 A |
| 31 | Relay T08-T17 in CVM and BC | 3 A |
| 32 | Swinging door | 15 A |
| 33 | Air heater / Iveco Daily 4 Cigarette lighter fuse | 15 A |
| 34 | 12V Power Outlet | 20 A |
| 35 | ABS or ESP. | 10 A |
| 36 | Central locking system | 20 A |
| 37 | Switches for brake lights and various loads | 7,5 A |
| 38 | BC / Roof lamps internal relays power supply | 10 A |
| 39 | Car radio - chrono-tachograph | 15 A |
| 40 | Right rear window heater | 10 A |
| 41 | Left rear window heater | 10 A |
| 42 | Back-up lamp switch | 5 A |
| 43 | Windscreen wiper | 20 A |
| 44 | Empty | - |
| 45 | Empty | - |
| 46 | Empty | - |
| 47 | Driver's window elevator | 25 A |
| 48 | Passenger window elevator | 25 A |
| 49 | Climate control system ECU, car stereo, heated seats | 15 A |
| 50 | Airbag system | 5 A |
| 51 | Chrono-tachograph | 5 A |
| 52 | Empty | - |
| 53 | Instrument cluster, rear fog lights | 7,5 A |
| Relays | ||
| T-01 | Right and left dipped headlights | |
| T-11 | Rear window heater relay | |
| T-12 | Cigarette lighter / 12V socket / heater or climate control system | |
| T-13 | Unlocking the power supply from the key | |
