The Hyundai Santa Fe is a mid-size crossover SUV built on the Sonata platform. Named after the city in New Mexico, this model was introduced in 2000 as Hyundai’s first crossover. In this article, we provide a detailed breakdown of the fuse box diagrams and relay layouts for the first-generation Hyundai Santa Fe (SM chassis) covering model years 2000, 2001, 2002, 2003, 2004, 2005, and 2006.
Here you will find component locations and photos of the power distribution boxes. Fuses for the “Cigarette Lighter” and “Fuel Pump” circuits are highlighted in bold.
Engine Compartment
Located adjacent to the battery.
General view of the underhood fuse box.
| Diagram | ||
|---|---|---|
|
||
| No. | Description | A |
| ALT | Alternator | 140 |
| B + | Tail lamp relay, fuses 11–17, power connector | 50 |
| IGN | Starter relay, ignition switch | 50 |
| BLR | A/C blower motor fuse, fan relay | 40 |
| ABS.1 | ABS control module, diagnostic link connector | 30 |
| ABS.2 | ABS control module | 30 |
| ECU | Engine control relay | 40 |
| P / W | Power window relay, fuse 26 | 30 |
| RAD FAN | Radiator fan relay | 40 |
| C / FAN | Condenser fan relay | 20 |
| FRT FOG | Front fog lamp relay | 15 |
| H / LP (LH) | Left headlight, instrument cluster, DRL control module | 10 |
| H / LP (RH) | Right headlight | 10 |
| ECU # 1 | Ignition failure sensor, oxygen sensor | 20 |
| ECU # 2 | Fuel injectors | 20 |
| ECU # 3 | Engine management system, ECM, PCM | 10 |
| ECU (B +) | Fuel pump relay, ECM, TCM, alternator, PCM | 15 |
| ATM | Transaxle monitoring relay, 4WD control module | 20 |
| HORN | Horn relay | 10 |
| A / C | A/C compressor relay | 10 |
| ST SIG | Start signal (PCM, ECM) | 10 |
Passenger Compartment
Located beneath the instrument panel on the driver’s side.
General view of the passenger compartment fuse box.
| Diagram | ||
|---|---|---|
|
||
| No. | Description | A |
| F1 | Cigarette lighter and 12V power outlet | 20 |
| F2 | Audio system, power exterior mirrors | 10 |
| F3 | Digital clock, rear power outlet | 15 |
| F4 | Cruise control system | 10 |
| F5 | Headlight relay | 10 |
| F6 | Heated seats | 20 |
| F7 | Rear wiper motor control | 10 |
| F8 | Heated rear window (defroster), power exterior mirrors | 10 |
| F9 | A/C control, power sunroof, electrochromic interior mirror | 10 |
| F10 | Spare / Reserve | - |
| F11 | Interior lamps, door courtesy lamps, door switches, manual A/C system, HomeLink module | 10 |
| F12 | Digital clock, ETACM, audio system, security alarm siren | 15 |
| F13 | Audio power amplifier | 20 |
| F14 | Brake lamps, Data Link Connector (DLC) | 10 |
| F15 | Hazard warning lamps | 10 |
| F16 | Power seats, rear wiper motor control | 25 |
| F17 | Power sunroof control module | 20 |
| F18 | Blower motor / heater relay | 30 |
| F19 | Instrument cluster, alternator pre-excitation resistor, ETACM, auto-light sensor, DRL control module | 10 |
| F20 | SRS (Airbag) control module | 15 |
| F21 | ECM (2.7L V6), PCM (2.4L I4 Automatic), ECM (2.4L I4 Manual) | 10 |
| F22 | Instrument cluster (Airbag indicator) | 10 |
| F23 | ABS control module, G-sensor, ABS bleeding connector, 4WD control module | 10 |
| F24 | Turn signal lamps | 10 |
| F25 | Backup lamps, TCM, ETS control module, ignition failure sensor | 10 |
| F26 | Power door lock/unlock relays | 20 |
| F27 | Left tail/parking lamp, turn signal lamp, license plate illumination light | 10 |
| F28 | Right tail/parking lamp, fog lamp relay, headlight switch | 10 |
| F29 | ETS control module (3.5L V6), safety relay | 15 |
| F30 | Radiator fan relay, condenser fan relay | 10 |
| F31 | Front wiper motor, wiper relay, windshield washer motor | 20 |
Located above the fuse panel are two relays:
R1 – Power windows;
R2 – Rear window defroster.
I changed the starter in my 2002 Hyundai Santa Fe it was running really good but when I changed it out and put a new one all it does is crank over turned on one time for about 20 minutes turned off and I cannot get it to start again can somebody please help me